Lippert Components Ground Control TT Installation And Owner's Manual
  1. Manuals
  2. Brands
  3. Lippert Components Manuals
  4. Lifting Systems
  5. ground control TT
  6. Installation and owner's manual

Lippert Components Ground Control TT Installation And Owner's Manual

Leveling onecontrol touch panel
Hide thumbs Also See for Ground Control TT:
Table of Contents

Advertisement

Quick Links

Table of Contents

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Trailer Weight Rating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Resources Required . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Measuring Departure and Approach Angle . . . . . . . . . . . . . 4
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Bolt on Spacer Kits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Front Spacer Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
C-Jack Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Power Tongue jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Installing Leveling Sensors . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Installing the Controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Installing the Touch Panel/Pad . . . . . . . . . . . . . . . . . . . . . . . 10
OneControl Touch Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Auto Leveling Control Touch Pad . . . . . . . . . . . . . . . . . . . . . 11
Operation -
Power Tongue Jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Unhitching from Tow Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 12
Reconnecting to Tow Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 12
Auto Leveling Control Touch Pad Diagram . . . . . . . . . . . . 13
Basic Tongue Jack Operation . . . . . . . . . . . . . . . . . . . . . . . . 13
Unhitching From Tow Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 13
Auto Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Hitch Recognition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
OneControl Touch Panel Diagram . . . . . . . . . . . . . . . . . . . . 15
lippertcomponents.com
574-537-8900
Leveling OneControl
Touch Panel
(For Aftermarket Application)
TT Leveling
OneControl
(For Aftermarket Applications)
Operation - OneControl Touch Panel . . . . . . . . . . . . . . . . . 16
Basic Jack Operation in Standard Mode . . . . . . . . . . . . . . . 16
Basic Jack Operation in Manual Mode . . . . . . . . . . . . . . . . 16
Unhitching from Tow Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 17
Auto Leveling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Hitch Recognition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Touch Panel Diagram - OneControl App . . . . . . . . . . . . . . 19
Operation - OneControl App . . . . . . . . . . . . . . . . . . . . . . . . . 20
Accessing the OneControl App . . . . . . . . . . . . . . . . . . . . . . 20
Basic Jack Operation in Standard Mode . . . . . . . . . . . . . . . 21
Basic Jack Operation in Manual Mode . . . . . . . . . . . . . . . . 21
Standard and Manual Modes . . . . . . . . . . . . . . . . . . . . . . . . 21
Unhitching from Tow Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 22
Auto Leveling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Hitch Recognition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Remote Diagram - Optional . . . . . . . . . . . . . . . . . . . . 23
™
or OneControl App . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Basic Jack Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Unhitching from Tow Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 25
Auto Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Red/Green LED Indicator on
Auto Leveling Control Touch Pad . . . . . . . . . . . . . . . . . . . . . 26
OneControl App . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Touch Panel or OneControl App . . . . . . . . . . . . . . . . . . . . . . 27
Manual Override . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Zero Point Calibration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
To set the zero point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Preventive Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
1
TT
®
®
Rev: 08.17 - GC
TT Leveling OCTP
®
™
®
™

Advertisement

Table of Contents
loading

Related Manuals for Lippert Components Ground Control TT

Summary of Contents for Lippert Components Ground Control TT

  • Page 1: Table Of Contents

    Ground Control ® Leveling OneControl ™ Touch Panel Installation and Owner’s Manual (For Aftermarket Application) Ground Control ® TT Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Table of Contents Operation - OneControl Touch Panel ....16 Basic Jack Operation in Standard Mode .

  • Page 2: Introduction

    (For Aftermarket Applications) Introduction NOTE: This manual is specific to travel trailer applications only. With the push of a button, the Ground Control TT Leveling System levels and stabilizes a trailer quickly and accurately, enhancing the overall camping experience. It MOVING PARTS CAN PINCH, CRUSH OR CUT.

  • Page 3: Parts List

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Parts List Number Part # Description Number Part # Description 425306 Auto Leveling Control Touch Pad 1 & 2 672136 TT Leveling Aftermarket Kit 421366 Power Tongue Jack with Bolts 406345 OneControl Touch Panel 333041 Canbus Terminating Resistor...

  • Page 4: Measuring Departure And Approach Angle

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Measuring Departure and Approach Angle Departure and approach angles are measured by running a string line from the meeting point of the tire and ground up at an angle to the lowest point on the front or rear of the trailer.
  • Page 5 Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) 3. Use clamps to hold the I-beam mounting bracket to the 8. Align the tabs provided on the I-beam mounting bracket frame rail. (Fig.5A) with the slotted holes on the spacer bracket (Fig.5B).

  • Page 6: Front Spacer Kit

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) 13. Insert four " hex cap screw bolts (Fig.7A) with 3. Secure the bolts with a " flat washer (Fig.8B) and a " " flange nut (Fig.8C). Torque to 23 ft-lbs. flat washer through the spacer bracket and center tube.

  • Page 7: Power Tongue Jack

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) 4. Align the 3 holes in the Power Tongue Jack mounting plate (Fig.11A) with the 3 holes in the coupler (Fig.11B). THE TRAILER MUST BE SUPPORTED PER MANUFACTURER SPECIFICATIONS BEFORE WORKING UNDERNEATH.

  • Page 8: Determining The Mounting Position And Installing Leveling Sensors

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Optional Drop Leg Foot Pad power Part Number: 405217 tongue jack The Power Tongue Jack has an option to replace the foot front of trailer pad with a Drop Leg foot pad.
  • Page 9 Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) The Leveling Sensors (Fig.15) must be oriented on the NOTE: The wire harness must be pointed toward the crossmembers with the arrows on the top of the sensor front of the trailer.

  • Page 10: Installing The Controller

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) 4. Connect the sensor harness to the 3-pin Deutsch 2. Attach the power and ground harnesses to the Connector on the sensor (Fig.20A) and run the harness corresponding posts on the controller with the provided through the frame and up to the compartment where the keps nuts and then connect the harnesses to the correct...

  • Page 11: Auto Leveling Control Touch Pad

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) NOTE: It is recommended to wire the canbus power Auto Leveling Control Touch Pad connector to the controller. The canbus power connector 1. Determine where to mount the Auto Leveling Control MUST be powered from a fused power source.

  • Page 12: Power Tongue Jack

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Operation - Power Tongue Jack 5. Press “RET” 2 times and hold on the 3rd time approximately 5 seconds until the Power Tongue Jack NOTE: The “On” and “Off” switch (Fig.27A) controls the stops.

  • Page 13: Auto Leveling Control Touch Pad Diagram

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Auto Leveling Control Touch Pad Diagram Fig.28 Callout Description Red/Green LED - Indicates the status of the system. Up Arrow - Extends the Power Tongue Jack. To turn on the touch pad, press the Up and Down arrow buttons at the same time.

  • Page 14: Auto Level

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) NOTE: The touch pad will remain on as long as the user is G. Trailer will level front-to-back and then side-to-side. pressing buttons. It will time out after approximately 5 minutes H.

  • Page 15: Onecontrol Touch Panel Diagram

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) OneControl Touch Panel Diagram leveling in standard mode jack buttons in manual mode See Fig.32 Fig.29 Callout Description Jack Buttons - Select Front, Rear, Right and Left jacks to be operated depending on mode. Jacks available to be operated will be highlighted in blue.

  • Page 16: Ground Control

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Operation - OneControl Touch Panel BE SURE TO PARK THE TRAILER ON SOLID AND LEVEL GROUND. PRIOR TO OPERATION, CLEAR ALL JACK LANDING LOCATIONS OF DEBRIS AND OBSTRUCTIONS. THE LOCATIONS SHOULD ALSO BE FREE OF SURFACE DEPRESSIONS AND MOISTURE.

  • Page 17: Unhitching From Tow Vehicle

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) OneControl Touch Panel in NOTE: To operate jacks individually, press “EXTEND” Standard and Manual Modes or “RETRACT” then press the “LEFT” (Fig.32A) or “RIGHT” (Fig.32C) button while simultaneously pressing Standard Mode Features the “FRONT”...

  • Page 18: Auto Leveling

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Auto Leveling Panel or App; e.g., “FRONT” button operates only the front jacks, etc. (“See Operation - OneControl Touch Panel” or 1. Prior to auto leveling, ensure the trailer is unhitched “Operation - OneControl App”...

  • Page 19: Touch Panel Diagram - Onecontrol App

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Touch Panel Diagram - NOTE: The OneControl Leveling App is available on iTunes for iPhone and iPad and also on Google Play ® ® ® ™...

  • Page 20: Operation - Onecontrol App

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Operation - OneControl App NOTE: If the device states “Unresolved Network Connection,” retry connecting to the myRV wireless NOTE: The OneControl App will only function if the trailer network and/or wait for the connection to resolve and is equipped with the myRV wifi hub (Fig.34).

  • Page 21: Basic Jack Operation In Standard Mode

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Basic Jack Operation in Standard Mode OneControl Touch Panel App in Standard and Manual Modes To reach Standard Mode (Fig.33) for leveling: Standard Mode Features 1.

  • Page 22: Unhitching From Tow Vehicle

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) NOTE: The jacks operate in pairs. If at any time in Auto Leveling manual mode the jacks operate individually, the Twist 1. Prior to auto leveling, ensure the trailer is unhitched Protection Prevention System has been activated to from the tow vehicle and the tow vehicle is parked a prevent frame twist.

  • Page 23: Hitch Recognition

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Linc Remote Diagram - Optional ™ Hitch Recognition 1. Power on the OneControl Touch Panel App. Part Numbers: 329164 - Remote & 267401 - Charger 2.

  • Page 24: Configuring Linc Remote To Sync To Onecontrol Touch Panel Or Onecontrol App

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Configuring Linc Remote to Sync to OneControl Touch Panel or OneControl App 1. Turn on the Linc Remote (Fig.38I) and enter a PIN. 2. Choose “Leveler” from the menu screen. 3.

  • Page 25: Basic Jack Operation

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Basic Jack Operation Auto Level 1. Prior to auto leveling, ensure the trailer is unhitched A. Press “EXTEND” (Fig.38E) or “RETRACT” (Fig.38A). Press “Front” arrow (Fig.38B) to operate Power Tongue from the tow vehicle and the tow vehicle is parked a safe distance away from the trailer.

  • Page 26: Troubleshooting

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Troubleshooting Red/Green LED Indicator on Auto Leveling Control Touch Pad What is Happening? Why? Touch panel is locked. Solid Green Touch panel is active. Blinking Green Jacks are moving.

  • Page 27: Special Jack Error Codes On Onecontrol Touch Panel Or Onecontrol App

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Special Jack Error Codes on OneControl A. Press “EXTEND” and “FRONT” to extend the front jacks (if required).Refer to “Operation - OneControl Touch Panel” Touch Panel or OneControl App and “Operation - OneControl App.”...

  • Page 28: Zero Point Calibration

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) C-Jacks Manual Override Jack Manual Override Nut: NOTE: For ease of manual override it is recommended to Tools needed: " socket wrench unplug the power harness to the motor prior to performing 1.

  • Page 29: Preventive Maintenance

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) To set the zero point 6. Press “ENTER” (Fig.52A). The following procedure works from Standard Mode only. (See “Operation OneControl Touch Panel”) 7. Screen will show “Zero Point Stability Check ... Please Wait”...

  • Page 30: Wiring Diagram

    Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual Wiring Diagram (For Aftermarket Applications) NOTE: This system requires two canbus terminating resistors: one on the controller and one on the back battery of the OneControl Touch Panel. power tongue jack Linc remote...
  • Page 31 Ground Control ® Leveling OneControl ® Touch Panel Installation and Owner’s Manual (For Aftermarket Applications) Notes lippertcomponents.com 574-537-8900 Rev: 08.17 - GC TT Leveling OneControl Touch Panel ® ®...
  • Page 32 (For Aftermarket Applications) Notes Manual information may be distributed as a complete document only, unless Lippert Components provides explicit consent to distribute individual parts. All manual information is subject to change without notice. Revised editions will be available for free download at www.lippertcomponents.com.

Table of Contents