General; General Safety Information; Precautions - Riello ALUDOMUS SOLAR KV/200 20 ISC SOLAR Installation And Maintenance Manual

1

GENERAL

1 . 1 General safety information

9
As soon as you open the packaging, check imme-
diately that the contents are all present and unda-
maged. Contact the
R
9
This system must be installed by a legally qualified
heating engineer. On completion of the installation,
the installer must issue the owner with a declara-
tion of conformity confirming that the installation
has been completed to the highest standards in
compliance with the instructions provided by
in this instruction manual, and that it conforms to
all applicable laws and standards.
9
The boiler must only be used for the purpose spe-
cified by ALUDOMUS SOLAR and for which it is desi-
gned. The manufacturer declines all responsibility,
contractual or other, for damage to property or in-
jury to persons or animals caused by improper in-
stallation, adjustment, maintenance or use.
9
If you notice any water leaking from the boiler, di-
sconnect it immediately from the mains electricity
supply, shut off the water supply, and notify your
local Technical Assistance Centre or a qualified
R
heating engineer immediately.

1 .2 Precautions

The operation of any appliance that uses fuel, electrical
power and water demands that a number of funda-
mental safety precautions be respected. In particular:
0
Do not allow children or infirm persons to operate
the boiler unsupervised.
0
Do not operate any electrical devices or equipment,
including switches or domestic appliances, etc., if
you can smell fuel or fumes. If you detect any su-
spicious smells:
− Ventilate the room by opening all doors and win-
dows;
− Close the fuel shut-off cock;
− Report the fault immediately to the
cal Assistance Service or a professionally quali-
fied heating engineer.
0
Do not touch the boiler when barefoot or wet.
0
Never clean or service the boiler without first di-
sconnecting it from the mains electricity supply by
turning it off at the mains power switch off and at
the control panel.
0
Do not tamper with or adjust the safety or control
devices without prior authorisation and instruc-
tions from the boiler's manufacturer.
.
R
R Techni-
9
Periodically check that operating pressure in the-
water circuit is over 1 bar. If water pressure is consi-
stently low, contact
vice or a professionally qualified heating engineer.
9
If the boiler is not going to be used for an extended
period of time, proceed as follows to prepare it for
shut-down:
− Turn the boiler OFF at the control panel.
− Turn the main power switch OFF .
− Close the fuel cock and heating circuit water cock.
− Drain the central heating circuit if there is any risk
of freezing.
9
The boiler must be serviced at least once a year.
9
If the boiler is destined to heat low temperatu-
re (under-floor) heating systems, it must be fitted
with an accessory mixer valve kit.
9
This instruction manual is an integral part of the
boiler. It must be kept safe and must ALWAYS ac-
company the boiler, even if it is sold to another
owner or transferred to another user or to another
installation. If you damage or lose this manual, or-
der a replacement immediately from your local
Technical Assistance Centre.
0
Never pull, disconnect, or twist the electrical cables
coming from the boiler even if it is disconnected
from the mains electricity supply.
0
Do no obstruct or restrict the vents in the room
where the appliance is installed. Adequate ventila-
tion is essential for correct combustion.
0
Do not expose the boiler to the elements. It is not
designed to work outdoors and is not fitted with
the necessary automatic anti-frost systems to do so.
0
Do not switch the boiler off if outside temperature
drops below ZERO (risk of freezing).
0
Do not leave flammable substances or containers in
the room where the boiler is installed.
0
Do not dispose of packaging material into the en-
vironment, or leave it within the reach of children,
since it can become a potential hazard. Dispose of
packaging material in compliance with applicable
legislation.
5
's Technical Assistance Ser-
R
R
GENERAL