Jeep Wrangler 1997 Manual page 1147

TJ
Description Group-Page
STOP LAMP SWITCH INPUT; 8W-35
ALL-WHEEL ANTI-LOCK BRAKES . . . . . . 8W-35-2
STOP LAMPS AND CHMSL LAMPS . . . . 8W-51-1
STRENGTH, FASTENER . . . . . . . . . . . . . . . Intro .-6
STRIKER, FULL DOOR LATCH . . . . . . . . . . .23-22
STRIKER, GLOVE BOX LATCH . . . . . . . . . . . 8E-23
STRIKER, HALF DOOR LATCH . . . . . . . . . . . 23-27
STRIKER, TAILGATE LATCH . . . . . . . . . . . . . 23-44
STUDS, STEERING KNUCKLE AND BALL . . . 3-21
STUDS, WHEEL MOUNTING . . . . . . . . . . . . . 2-10
SUNVISOR . . . . . . . . . . . . . . . . . . . . . . . . . . 23-40
SUPPLY-PRIMARY, FIVE VOLT SENSOR . . 14-22
SUPPLY-SECONDARY, FIVE VOLT
SENSOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-22
SUPPORT BRACKET, REARVIEW MIRROR .23-38
SUPPORT CYLINDER, LIFTGATE GLASS . . . 23-40
SUPPORT, OIL PUMP AND REACTION
SHAFT . . . . . . . . . . . . . . . . . . . . . . 21-126,21-143
SUPPORT, OVERRUNNING CLUTCH/LOW-
SWITCH, POWER STEERING PRESSURE ;
SW-30 FUEUIGNITION SYSTEMS . . . . . . 8W-30-5
SWITCH, POWER STEERING PRESSURE;
FUEL SYSTEM ., . . . . . . . . . . . . . . . ., . . . .14-33
SWITCH, STOP LAMP . . . . . . . . 5-14,5-26,5-2,5-8
SWITCHES, CHIME WARNING SYSTEM
. . . . 8U-4
SWITCHES, WIPER AND
WASHER . . . . . . . . . . . . . . . . . . . 8K-10,8K-3,8K-6
SWITCH-2 .5L ENGINE, POWER
STEERING PRESSURE . . . . . . . . . . . . . . . . . 14-37
SWITCH-PCM INPUT, BRAKE . . . . . . . . . . 14-22
SWITCH-PCM INPUT, POWER
STEERING PRESSURE . . . . . . . . . . . . . . . . . 14-25
SWITCH-PCM INPUT, TRANSMISSION
PARK/NEUTRAL . . . . . . . . . . . . . . . . . . . . . . 14-24
SYMBOLS . . . . . . . . . . . . . . . . . . . . . . . . 8W-01-3
SYMBOLS, INTERNATIONA
. . . . . . . . . . . . . . 0-1
SYMBOLS, INTERNATIONAL CONTROL
AND DISPLAY . . . . . . . . . . . . . . . . . . . . . . Intro.-4
Description
Group-Page
SYMBOLS, INTERNATIONAL VEHICLE
CONTROL AND DISPLAY . . . . . . . . . . . . . Intro .-4
SYNCHRO ASSEMBLY, FIFTH GEAR . . . . . . 21-46
SYSTEM, AIRBAG . . . . . . . . . . . . . . . . 8M-3,8M-4
SYSTEM, ANTILOCK BRAK . . . . . . . . . . . . . 5-30
SYSTEM, AUDIO
. . . . . . . . . . . . . . . . . . . . . . 8F-2
SYSTEM, BASE BRAKE . . . . . . . . . . . . . . . 5-1,5-6
SYSTEM, BLEEDING ABS BRAK . . . . . . . . . 5-33
SYSTEM, BRAKE . . . . . . . . . . . . . . . . . . . . . . . 5-2
SYSTEM CAPACITIES, COOLING . . . . . . . . . . 7-33
SYSTEM CHARGE, REFRIGERANT
. . . . . . . . 24-19
SYSTEM, CHARGING; SW-20 CHARGING
SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . .8W-20-1
SYSTEM, CHARGING ; CHARGING
SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . .SC-2
SYSTEM COMPONENTS, COOLING . . . . . . . . . 7-2
SYSTEM, COOLANT RESERVE/
OVERFLOW . . . . . . . . . . . . . . . . . . . . . . . . . . .7-4
SYSTEM COOLANT ROUTING . . . . . . . . . . . . . 7-2
SYSTEM, STARTING . . . . . . . . . . 8B-10,8B-2,8B-3
SYSTEM, STEERING . . . . . . . . . . . . . . . . . . . 19-1
SYSTEM SWITCHES, CHIME WARNING . . . . 8U-4
SYSTEM, TURN SIGNAL . . . . . . . . . . . . . . . . 8J-1
SYSTEM, VACUUM . . . . . . . . . . . . . . . . . . . 24-11
SYSTEM, WINDSHIELD WASHER . . . . . . . . . 8K-1
SYSTEM, WINDSHIELD WIPER . . . . . . . . . . . 8K-1
SYSTEM-AUTOMATIC
TRANSMISSIONS, STARTING . . . . . . . . . 8W-21-1
SYSTEM-MANUAL TRANSMISSION,
STARTING . . . . . . . . . . . . . . . . . . . . . . . . 8W-21-1
SYSTEMS, LAMP . . . . . . . . . . . . . . . . . . . . . 8L-14
SYSTEMS, MONITORED . . . . . . . . . . . . . . . . 25-7
SYSTEMS, TURN SIGNAL AND HAZARD
WARNING . . . . . . . . . . . . . . . . . . . . . . . . . . .8J-2
SYSTEMS, WASHER . . . . . . . . . . . . . . . . . . . 8K-5
SYSTEMS, WIPER . . . . . . . . . . . . . . . . . . . . . 8K-4
TORQUE CHART . . . . . . . . . . . . . . . . . . . . . . . 5-37
TACHOMETER; 8W-40 INSTRUMENT
CLUSTER . . . . . . . . . . . . . . . . . . . . . . . . . 8W-40-1
INDEX 1 3
Description Group-Page
TACHOMETER ; INSTRUMENT PANEL
SYSTEMS . . . . . . . . . . . . . . . . . . . . . . 8E-11,8E-5
TACHOMETER-PCM OUTPUT . . . . . . . . . . 14-27
TAIL LAMPS AND REAR LICENSE PLATE
LAMPS . . . . . . . . . . . . . . . . . . . . . . . . . . 8W-51-1
TAILGATE
. . . . . . . . . . . . . . . . . . . . . . . . . . . 23-42
TAILGATE ADJUSTMEN . . . . . . . . . . . . . . .23-45
TAILGATE HINGE . . . . . . . . . . . . . . . . . . . . .23-43
TAILGATE LATCH . . . . . . . . . . . . . . . . . . . . . 23-44
TAILGATE LATCH STRIKE . . . . . . . . . . . . . 23-44
TAILGATE LOCK CYLINDER
. . . . . . . . . . . . .23-43
TAILGATE OUTSIDE HANDLE . . . . . . . . . . . . 23-43
TAILGATE WEATHERSTRIP AND
CHANNEL . . . . . . . . . . . . . . . . . . . . . . . . . . . 23-44
TAILPIPE ASSEMBLY, MUFFLER . . . . . . . . . . 11-4
TAIUSTOP/TURN SIGNAUBACK-UP
LAMP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-11
TAIL/TURN SIGNAUBACK-UP LAMP
BULB . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8L-8
TEST, AUTOMATIC SHUTDOWN (ASO)
RELAY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8D-5
TEST, CHECK COIL . . . . . . . . . . . . . . . . . . . . 8D-6
TEST, COLD CRANKING . . . . . . . . . . . . . . . . 8B-5
TEST, CONVERTER STALL . . . . . . . . . . . . . . 21-81
TEST, CRANKSHAFT POSITION SENSOR
. . . 8D-8
TEST, CURRENT OUTPUT . . . . . . . . . . . . . . . 8C-4
TEST, CYLINDER COMBUSTION
PRESSURE LEAKAGE . . . . . . . . . . . . . . . . . . .9-9
TEST, CYLINDER COMPRESSION
PRESSURE . . . . . . . . . . . . . . . . . . . . . . . . . . .9-9
TEST, FAILURE TO START . . . . . . . . . . . . . . . 8D-7
TEST FOR CHARGING SYSTEM
ON-BOARD DIAGNOSTIC . . . . . . . . . . . . . . . . 8C-5
TEST, FUEL INJECTOR . . . . . . . . . . . . . . . . . .14-7
TEST, HYDRAULIC PRESSURE . . . . . . . . . . 21-79
TEST, HYDROMETER . . . . . . . . . . . . . . . . . . . 8A-5
TEST, IGNITION-OFF DRAW . . . . . . . . . . . . . . 8A-9
TEST INDICATOR, BUILT-IN . . . . . . . . . . . . . . 8A-5
TEST, LOAD . . . . . . . . ., . . . ., . . . ., . . . . . .8A-7
REVERSE DRUM/REAR . . . . . . . . . . . . . . . 21-142
SUPPRESSION, RADIO NOISE . . . . . . . . . . . . SF-2
SURFACE TOUCHUP, PAINTED . . . . . . . . . . . 23-2
SUSPENSION ARM, LOWER . . . . . . . . . . 2-13,2-7
SUSPENSION ARM, UPPER . . . . . . . . . . 2-13,2-8
SUSPENSION, FRONT . . . . . . . . . . . . . . .2-11,2-6
SYSTEM, COOLING . . . . . . . . . . . . . . . . . 7-32,7-1
SYSTEM, CRANKCASE VENTILATION . . . . . 25-12
SYSTEM, DEFOGGER
. . . . . . . . . . . . . . . . . .8N-2
SYSTEM DESCRIPTION . . . . . . . . . . . . . . . . .25-1
SYSTEM DIAGNOSIS . . . . . . . . . . . . . . . . . . 14-20
SYSTEM DIAGNOSIS CHARTS, POWER
TAKE OUTS
. . . . . . . . . . . . . . . . . . . . . . . 8W-01-3
TANK CAPACITY, FUEL . . . . . . . . . . . . . . . . 14-16
TANK FILLER TUBE CAP, FUE
EMISSION CONTROL SYSTEMS . . . . 25-12,25-14
TANK FILLER TUBE CAP, FUEL ; FUEL
SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14-5
SUSPENSION, REAR . . . . . . . . . . . . . . . . . . . 2-12 STEERING . . . . . . . . . . . . . . . . . . . . . . . . . . .19-2 TANK, FUEL . . . . . . . . . . . . . . . . . . . . . 14-13,14-4
SWITCH, ACCELERATION . . . . . . . . . . . 5-33,5-36 SYSTEM DIAGNOSIS CONT, TANK SKID PLATE, FUEL . . . . . . . . . . . . . . . . 13-7
SWITCH AND KEY CYLINDER, IGNITION . . 8D-20 COOLING . . . . . . . . . . . . 7-14,7-15,7-16,7-17,7-18 TAPPETS, HYDRAULIC . . 9-35,9-48,9-70,9-84,9-8
SWITCH AND KEY LOCK CYLINDER, SYSTEM DIAGNOSIS, COOLING . . . . . . . . . . 7-13 TC-SERIES PUMP PULLEY . . . . . . . . . . . . . . . . 19-7
IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8D-5 SYSTEM DIAGNOSIS, EXHAUST . . . . . . . . . . 11-3 TC-SERIES PUMP RESERVOIR . . . . . . . . . . . 19-7
SWITCH AND PLUG LOCATIONS, SYSTEM DIAGNOSIS, STARTING . . . . . . . . . 8B-4 TEMPERATURE CONTROL CABLE . . . . . . . . 24-28
TRANSMISSION . . . . . . . . . . . . . . . . . . . . . . 21-35 SYSTEM DIAGNOSTIC TROUBLE CODE TEMPERATURE GAUGE, COOLANT . . . . 8E-3,8E-9
SWITCH BEZEL, ACCESSORY . . . . . . . . . . . 8E-21 DESCRIPTIONS, CHARGING . . . . . . . . . . . . .SC-6 TEMPERATURE GAUGE, ENGINE
SWITCH, BLOWER MOTOR . . . . 24-15,24-28,24-5 SYSTEM, DRAINING COOLING . . . . . . . . . . . 7-23 COOLANT . . . . . . . . . . . . . . . . . . . . . . . .8W-40-2
SWITCH BY-PASS, CLUTCH INTERLOCK SYSTEM EVACUATE, REFRIGERAN . . . . . . 24-19 TEMPERATURE SENSOR, BATTERY;
SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6-1 SYSTEM, EVAPORATION (EVAP) 8W-30 FUEUIGNITION SYSTEMS . . . . . . 8W-30-3
SWITCH, DEFOGGER . . . . . . . . . . 8N-2,8N-3,8N-5 CONTROL . . . . . . . . . . . . . . . . . . . . . . . . . .25-11 TEMPERATURE SENSOR, BATTERY;
SWITCH, DRIVER AIRBAG TRIM COVER SYSTEM, EXHAUST . . . . . . . . . . . . . . . . . . . . 11-1 CHARGING SYSTEM . . . . . . . . . . . 8C-2,8C-5,8C-8
AND HORN . . . . . . . . . . . . . . . . . . . . . . . . . . 8M-6 SYSTEM FOR LEAKS, TESTING COOLING . . . 7-19 TEMPERATURE SENSOR, ENGINE
SWITCH, DRIVER DOOR AJAR . . . . . . . . . . . 8U-1 SYSTEM,FUEL . . . . . . . . . . . . . . . . . . . . . . 14-40 COOLANT; 8W-30 FUEUIGNITION
SWITCH, DRIVER DOOR JAMB . . . . . . . . . . . 8U-2 SYSTEM, FUEL DELIVERY . . . . . . . . . . . . . . .14-3 SYSTEMS . . . . . . . . . . . . . . . . . . . . . . . .8W-30-3
SWITCH, DRIVER SEAT BELT . . . . . . . . . . . . 8U-2 SYSTEM, FUEL INJECTION . . . . . . . . . . . . .14-17 TEMPERATURE SENSOR, ENGINE
SWITCH, FOUR-WHEEL DRIVE
CONT~OL
4WD) ; SYSTEM, HAZARD WARNING . . . . . . . . . . . . 8J-1 COOLANT; FUEL SYSTEM . . . . . . . . . 14-32,14-38
8W-31 TRANSMISSION SYSTEM HOSES, COOLING . . . . . . . . . . . 7-33,7-6 TEMPERATURE SENSOR, ENGINE
SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . 8W-31-1 SYSTEM, HYDRAULIC CONTROL . . . . . . . . 21-74 COOLANT; IGNITION SYSTEM .8D-10,8D-16,8D-5
SWITCH, FOUR-WHEEL DRIVE (4WD) ; SYSTEM, IGNITION . . . . . . . . . . . . . . . . . . . . 8D-1 TEMPERATURE SENSOR, INTAKE AIR . . 8W-30-4
8W-40 INSTRUMENT CLUSTER . . . . . . . 8W-40-2 SYSTEM LAMP, ANTI-LOCK BRAKE . . 8E-12,8E-5 TEMPERATURE SENSOR, INTAKE
SWITCH, HEADLAMP ; CHIME/BUZZ SYSTEM LEAKS, REFRIGERANT . . . . . . . . . 24-18 MANIFOLD AIR ; FUEL SYSTEM . . . . . 14-33,14-38
WARNING SYSTEMS . . . . . . . . . . . . . . 8U-2,8U-3 SYSTEM, LUBRICATION . . . . . . . . . . . . 9-17,9-54 TEMPERATURE SENSOR, INTAKE
SWITCH, HEADLAMP ; INSTRUMENT SYSTEM, MANUAL STEERING . . . . . . . . . . . 19-22 MANIFOLD AIR ; IGNITION
PANEL SYSTEMS . . . . . . . . . . . . . . . . . . . . . 8E-19 SYSTEM, METRIC . . . . . . . . . . . . . . . . . . . Intro .-7 SYSTEM . . . . . . . . . . . . . . . . . . 8D-10,8D-17,8D-5
SWITCH, HIGH PRESSURE CUT-OFF . . . . . 24-17, SYSTEM, ON-BOARD DIAGNOSTIC TEST TEMPERATURE SENSOR-PCM INPUT,
24-24,24-6 FOR CHARGING . . . . . . . . . . . . . . . . . . . . . . . 8C-5 BATTERY . . . . . . . . . . . . . . . . . . . . . . . . . . .14-22
SWITCH, HORN . . . . . . . . . . . . . . 8G-1,8G-2,8G-3 SYSTEM OPERATION, CHARGING . . . . . . . . . 8C-1 TEMPERATURE SENSOR-PCM INPUT,
SWITCH, IGNITION
. . . . . . . . . . . . . . . . . 8W-30-1
SYSTEM PRESSURE,FUEL . . . . . . . . . . . . . 14-16 ENGINE COOLANT . . . . . . . . . . . . . . . . . . . . 14-22
SWITCH INPUT, STOP LAMP ; 8W-30 SYSTEM PRESSURE RELEA TEMPERATURE SENSOR-PCM INPUT,
FUEUIGNITION SYSTEMS . . . . . . . . . . . . 8W-30-5 PROCEDURE-WITHOUT TEST PORT, INTAKE MANIFOLD AIR . . . . . . . . . . . . . . . . 14-24
SWITCH INPUT, STOP LAMP ; 8W-35 FUEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14-7 TENSION, BELT . . . . . . . . . . . . . . . . . . . . . . . 7-34
ALL-WHEEL ANTI-LOCK BRAKES . . . . . . 8W-35-2 SYSTEM PRESSURE RELEASE TENSIONER, PARKING BRAKE CABLE . . . . . . 5-27
SWITCH, KEY-IN IGNITION
. . . . . . . . . . . . . . 8U-2
PROCEDURE-WITH TEST PORT, FUEL . . . . . 14-7 TERMINAL REPLACEMENT . . . . . . . . . . 8W-01-10
SWITCH, LOW PRESSURE CYCLING SYSTEM, REAR WIPER . . . . . . . . . . . . . . 8W-53-2 TERMINAL REPLACEMENT, CONNECTOR .8W-01-9
CLUTCH . . . . . . . . . . . . . . . . . . . 24-18,24-26,24-7 SYSTEM, REAR WIPER AND WASHE . . . . .8K-2 TERMINAL SPREADING, CHECKING . . . . 8W-01-6
SWITCH, MULTI-FUNCTION . . . . . . 8J-2,8J-3,8J-4 SYSTEM, REFILLING COOLING . . . . . . . . . . . 7-23 TERM INAUCONNECTOR REPAIR-MOLEX
SWITCH, PARK/NEUTRAL POSITION ; SYSTEM RELAYS, ABS . . . . . . . . . . . . . . . . . 5-33 CONNECTORS . . . . . . . . . . . . . . . . . . . . . 8W-01-7
8W-30 FUEUIGNITION SYSTEMS . . . . . . 8W-30-4 SYSTEM RESISTANCE TESTS, CHARGING . . 8C-3 TERM INAUCONNECTOR REPAIR-
SWITCH, PARK/NEUTRAL POSITION ; SYSTEM SERVICE EQUIPMENT, THOMAS AND BETTS CONNECTORS . . . 8W-01-8
TRANSMISSION AND TRANSFER CASE . . . 21-77, REFRIGERANT . . . . . . . . . . . . . . . . . . . . . . . . 24-7 TEST ANALYSIS, STALL . . . . . . . . . . . . . . .21-81
21-97
SYSTEM SERVICE PORTS, REFRIGERANT . . 24-8 TEST, ANALYZING ROAD . . . . . . . . . . . . . . . 21-79