Automatic Transmission Unit (A340F) Removal - Toyota T100 1996 Service Manual

AT−34
1996 TOYOTA T100 (RM449U)
AUTOMATIC TRANSMISSION
REMOVAL
1.
2.
(a)
(b)
3.
(a)
(b)
Q02639
(c)
HINT:
At the time of reassembly, please refer to the following item.
Apply MP grease to the transfer shift lever.
Q02640
4.
Remove the 2 nuts and No.1 throttle cable clamp.
5.
6.
Remove the bolt and oil filler pipe with the O−ring.
HINT:
At the time of reassembly, please refer to the following item.Re-
place the used O−ring with a new one.
7.
D10996
8.
− AUTOMATIC TRANSMISSION UNIT (A340F)
REMOVE ENGINE UNDER COVER
DISCONNECT THROTTLE CABLE
Loosen the nut and disconnect the cable.
Remove the throttle cable from the clamp.
REMOVE TRANSFER SHIFT LEVER FROM INSIDE OF
VEHICLE
Remove the shift lever knob.
Remove the 4 screws and the boot.
Using pliers, remove the snap ring and pull out the shift
lever from the transfer.
REMOVE NO.1 THROTTLE CABLE CLAMP
JACK UP VEHICLE
REMOVE OIL FILLER PIPE
REMOVE FRONT AND REAR PROPELLER SHAFT
(See page PR−11)
REMOVE FRONT EXHAUST PIPE (See page EM−108)
AT02E−02