Preventive Maintenance; Warnings/Cautions; Regular Maintenance Activities; Cleaning Your Treadmill - CYBEX Treadmill Owner's Service Manual

Cybex Pro Treadmill Owner's & Service Manual

4 - Preventive Maintenance

Warnings/Cautions

All warnings and cautions listed in this chapter are as follows:
! WARNING: All maintenance activities shall be performed by qualified
personnel. Failure to do so could result in serious injury.
! WARNING: To prevent electrical shock, be sure that power is shut off
and the treadmill is unplugged from the electrical outlet
before performing any cleaning or maintenance procedures.
! WARNING: Keep wet items away from inside parts of the treadmill.
Electrical shock could occur even if the treadmill is
unplugged. Do not touch components on the lower board. A
charge can remain after unplugging the power cord and
turning off the treadmill.
! CAUTION: Be careful not to over tighten the belt. Over tightening the
belt can cause the belt to stretch and require replacement.

Regular Maintenance Activities

! WARNING: All maintenance activities shall be performed by qualified
personnel. Failure to do so could result in serious injury.
Preventive maintenance activities must be performed to maintain normal
operation of your treadmill. Keeping a log sheet of all maintenance actions will
assist you in staying current with all preventive maintenance activities. See
Service Schedule and Log Sheet located at the end of this chapter.
NOTE: Worn or damaged components shall be replaced immediately or the
treadmill removed from service until the repair is made.
NOTE: Cybex is not responsible for performing regular inspection and
maintenance actions for your treadmill. Instruct all personnel in
equipment inspection and maintenance actions and also in accident
reporting/recording. Contact Cybex Customer Service at 800-766-3211
or 508-533-4300 for any preventive maintenance or service concerns.

Cleaning Your Treadmill

When cleaning your treadmill spray a mild cleaning agent, such as a water and
dishsoap solution, on a clean cloth first and then wipe the treadmill with the
damp cloth.
Table of Contents . . . . . . . . . . . . . iii
4 Preventive Maintenance
Warnings/Cautions. . . . . . . . . . . . 4-1
Regular Maintenance . . . . . . . . . 4-1
Cleaning Your Treadmill . . . . . . . . 4-1
Running Belt Maintenance. . . . . . 4-2
Other Preventive Maintenance. . . 4-6
Service Schedule . . . . . . . . . . . . . 4-7
Log Sheet. . . . . . . . . . . . . . . . . . . 4-8
Page 4-1