CYBEX Treadmill Owner's Service Manual page 73

Cybex Pro Treadmill Owner's & Service Manual
B. Adjust the gap between the speed sensor and the flywheel to 3/16"
(.48 cm) and tighten the screw. See Figure 3.
Flywheel
Figure 3
5. Test for speed errors.
A. Connect the power cord to a power outlet.
B. Enter Test Mode.
C. Bring the speed of the treadmill up to maximum speed, 12.4 mph
(20 kph).
D. After reaching maximum speed take note of the actual speed that is
displayed in the lower left window. If it fluctuates in over 0.5 mph
increments then your speed sensor gap needs to be readjusted.
E. Press Stop and turn the power switch to the off (O) position.
F. Enter Test Mode again and check the error log for Error 3. If Error 3
occurred readjust the speed sensor and test again. NOTE: If you are
unsure whether an error is new you can clear the error log by pressing
the Scan key and then repeat steps 4A through 5F.
G. Exit Test Mode by pressing Stop.
6. Attach the motor cover.
A. Lower the motor cover center into position. See Figure 2.
B. Using a Phillips head screwdriver, tighten the three screws on each side.
Gap Speed Sensor Screw
Table of Contents . . . . . . . . . . . iii
Important Safety Instructions . . 1-2
Warning Decals. . . . . . . . . . . . . 1-4
Caution Decals . . . . . . . . . . . . . 1-7
Emergency Stop Key (e-stop). . 1-8
2 Technical Specifications
Specifications . . . . . . . . . . . . . . 2-1
3 Operation
Terms & Symbols Used . . . . . . 3-1
Quick Operation Guide . . . . . . 3-2
Detailed Operation Guide . . . . 3-2
Stopping the Treadmill . . . . . . . 3-4
Immobilization Method . . . . . 3-4
Emergency Dismount . . . . . . 3-4
Emergency Stop . . . . . . . . . . . . 3-4
Safety Sentry . . . . . . . . . . . . . . 3-4
Control During Operation . . . . . 3-5
Data Readouts . . . . . . . . . . . . . 3-6
Displaying Heart Rate . . . . . . . . 3-6
Heart Rate LED. . . . . . . . . . . . . 3-7
Use of Programs. . . . . . . . . . . . 3-8
Manual Mode . . . . . . . . . . . . . . 3-9
The Workout Profile . . . . . . . . . 3-9
Meaning of % Grade . . . . . . . . 3-9
Calorie Goal . . . . . . . . . . . . . . 3-10
5K Run . . . . . . . . . . . . . . . . . . 3-12
9 Holes . . . . . . . . . . . . . . . . . . 3-14
Heart Rate. . . . . . . . . . . . . . . . 3-16
Custom Program 1 . . . . . . . . . 3-18
Custom Program 2 . . . . . . . . . 3-20
Create a Custom Program . . . 3-22
4 Preventive Maintenance
Regular Maintenance Activities 4-1
Cleaning Your Treadmill . . . . . . 4-1
Running Belt Maintenance . . . . 4-2
Other Preventive Maintenance . 4-6
Service Schedule . . . . . . . . . . . 4-7
Log Sheet . . . . . . . . . . . . . . . . . 4-8
5 Removal & Replacement
Quick Setup . . . . . . . . . . . . . . . 5-1
Choosing & Preparing a Site . . 5-1
Electrical Power Requirements 5-2
Assembling the Treadmill . . . . . 5-2
Tools Required . . . . . . . . . . . . . 5-2
Testing the Treadmill Operation 5-11
Setting Operation Options . . . 5-12
6 Customer Service
7 Service
Warnings/Cautions . . . . . . . . . . 7-1
Test Mode . . . . . . . . . . . . . . . . . 7-2
LED Functions . . . . . . . . . . . . . 7-3
Key Functions . . . . . . . . . . . . . . 7-3
Error Codes. . . . . . . . . . . . . . . . 7-4
Motor Current & Voltage . . . . . 7-4
Speed Sensor Adjustment . . . . 7-6
Speed Calibration . . . . . . . . . . . 7-8
Running Belt & Deck . . . . . . . . 7-8
Rear Roller . . . . . . . . . . . . . . . . 7-9
Front Roller . . . . . . . . . . . . . . . 7-10
Drive Belt . . . . . . . . . . . . . . . . 7-11
Drive Motor . . . . . . . . . . . . . . . 7-13
Motor Brushes . . . . . . . . . . . . 7-16
Elevation Motor. . . . . . . . . . . . 7-19
Lower Control Board . . . . . . . 7-21
Power Cord. . . . . . . . . . . . . . . 7-24
Power Switch . . . . . . . . . . . . . 7-24
Line Filter . . . . . . . . . . . . . . . . 7-25
Upper Display Board . . . . . . . 7-27
Contact Heart Rate Board . . . 7-29
CSAFE Board . . . . . . . . . . . . . 7-30
Display Cable . . . . . . . . . . . . . 7-31
Display Overlays . . . . . . . . . . . 7-34
Parts List . . . . . . . . . . . . . . . . 7-36
Exploded View . . . . . . . . . . . . 7-39
Schematic. . . . . . . . . . . . . . . . 7-40
Page 7-7