General Information; General Safety; Service Rules - Honda VT600C Shadow VLX Service Manual

G E N ERAL SAFETY
S ERVI C E R U LES
M O D E L I D EN T I F I CATI O N
SPECIFICATI O N S
T O RQ U E VAL U ES

GENERAL SAFETY

I f the engine must be running to do some work, make sure the
areals well-ventilated. Never run the engine in an enclosed
area. The exhaust contains posisonous carbon monoxide gas
that may cause loss of consciousness and lead to death.
The battery generates hydrogen gas which can be highly explo­
sive. Do not smoke or allow flames or sparks near the battery,
especially while charging it.
Inhaled asbestos fibers have been found to cause respiratory
disease and cancer. Never use an air hose or dry brush to clean
brake assemblies. Use an OSHA-approved vacuum cleaner or
alternate method approved by OSHA designed to minimize
the hazard caused by airborne asbestos fibers.

SERVICE RULES

Use genuine H O N DA or HON DA-recommended parts and lubricants or their equivalents . Parts that don ' t meet H O N DA ' s
1.
design specifications may damage to the vehicle .
Use the special tools designed for this product to avoid damage and incorrect assembly.
2 .
3 . Use only metric tools when servicing the vehicle . Metric bolts, nuts, and screws are not i nterchangeable with English fas­
teners.
I nstal l new gaskets, 0-rings, cott e r pins, and lock plates when reassembling .
4.
When tightening bolts or nuts, beg i n with the larger-diameter or inner bolts first. Then tighten to the specified torque diag-
5 .
onally in steps, u nless a particular sequence is specified .
1-5
Clean parts in non-flammable or h i gh flash point solvent upon disassembly.
6.
7. Lubricate a ny sliding surfaces before reassembly.
8 . After reassembly, check all parts for proper installation and operation .
1 . GEN E RAL INFORMATION
1 - 1 TOOLS
1 - 1 CABLE & HARNESS ROUTING
1 -2 EMISSION CONTROL SYSTEMS
1 -3 EMISSION CONTROL I N FORMATION
LABELS
1 - 5
Gasoline is extremely flammable and
conditions Work in a well ventilated area with the engine
stopped. Do not smoke or allow flames or sparks in the work
area or where gasoline is stored.
The battery electrolyte contains sulfuric acid. Protect your
eyes, skin and clothing. In case of contact, flush thoroughly
with water and call a doctor if electrolyte gets in your eyes.
CAUTION :
Used engine oil may cause skin cancer if repeatedly left in con­
tact with the skin for prolonged periods. A lthough this is
unlikely unless you handle used oil on a daily basis, it is still
adviseable to thoroughly wash your hands with soap and
water as soon as possible after handling used oil.
1 -8
1 - 1 0
1 - 2 1
1 - 22
is
explosive under certain
1 - 1