Product Reference Guide - Datalogic Gryphon I GD4100 Product Reference Manual

In the event the battery pack leaks and the fluid gets into your eye, do not rub the eye. Rinse well
with water and immediately seek medical care. If left untreated, the battery fluid could cause
damage to the eye.
WARNING
• Always charge the battery at 32° – 104°F (0° - 40°C) temperature range.
• Use only the authorized power supplies, battery pack, chargers, and docks supplied by your Data-
logic reseller. The use of any other power supplies can damage the device and void your warranty.
• Do not disassemble or modify the battery. The battery contains safety and protection devices,
which, if damaged, may cause the battery to generate heat, explode or ignite.
CAUTION
• Do not place the battery in or near fire, on stoves or other high temperature locations.
• Do not place the battery in direct sunlight, or use or store the battery inside cars in hot weather.
Doing so may cause the battery to generate heat, explode or ignite. Using the battery in this man-
ner may also result in a loss of performance and a shortened life expectancy.
• Do not place the battery in microwave ovens, high-pressure containers or on induction cookware.
• Immediately discontinue use of the battery if, while using, charging or storing the battery, the bat-
tery emits an unusual smell, feels hot, changes color or shape, or appears abnormal in any other
way.
• Do not replace the battery pack when the device is turned on.
• Do not remove or damage the battery pack's label.
• Do not use the battery pack if it is damaged in any part.
• Battery pack usage by children should be supervised.
As with other types of batteries, Lithium-Ion (LI) batteries will lose capacity over time. Capacity
deterioration is noticeable after one year of service whether the battery is in use or not. It is
difficult to precisely predict the finite life of a LI battery, but cell manufacturers rate them at
500 charge cycles. In other words, the batteries should be expected to take 500 full discharge /
charge cycles before needing replacement. This number is higher if partial discharging /
recharging is adhered to rather than full / deep discharging, .
Storage of batteries for long time at fully charged status or at fully discharged status should be
avoided.
Only in case of long storage, to avoid deep discharge of the battery it is recommended to partially
recharge the battery every three months to keep the charge status at a medium level.
As a reference, run a fast recharge for 20 minutes every three months on unused products to avoid
any performance deterioration of the cell.
The useful life of LI batteries depends on usage and number of charges, etc., after which they
should be removed from service, especially in mission critical applications. Do not continue to
use a battery showing excessive loss of capacity, it should be properly recycled / disposed of and
replaced.
Collect and recycle waste batteries separately from the device in compliance with European
Directive 2006/66/EC, 2002/95/EC, 2002/96/EC and subsequent modifications, US and
China regulatory and others laws and regulations about the environment.

Product Reference Guide

Battery Safety
15