User I/O Interface - Branson 2000 Series Installation Manual

Start Switch Connection (Automation)

User I/O Interface

The user I/O is a standard interface for automation, provided on the power supply. It provides the ability for
the customer to make their own interface for their automation or special control or reporting needs. The
interface cable has an HD44 female D-shell connection on the rear of the power supply. The electrical inter-
face outputs may be configured for open collector mode or for signal mode (signal voltage levels as indi-
cated), by setting the user I/O DIP switch.
DIP switch SW1 for the user I/O is located next to the J3 on the back of the 2000-series power supply. User
I/O interface cable pinout is listed in
Figure 23 User I/O Cable Identification and Wire Color Diagram
User I/O Cable
Stripped and tinned one end,
HD-44 male connector other end
(cable length as ordered)
Insulation
Table 11 User I/O Cable Pin Assignments
Pin Signal Name
7 ACT_CLEAR
24 AMPLITUDE_OUT
2 CYCLE_ABORT
3 EXT_RESET
18 EXT_SEEK+
38 FREQ_OUT
6 G_ALARM
14 GEN_ALARM_RELAY_1
29 GEN_ALARM_RELAY_2
1 J3_1_INPUT
17 J3_17_INPUT
19 J3_19_INPUT
31 J3_31_INPUT
32 J3_32_INPUT
33 J3_33_INPUT
32
Table 11.
Wire Color Diagram
Two Colors = Insulator/Stripe
Three Colors = Insulator/Stripe/Dot
Stripe
Signal Type Direction
0V True Output
Analog Output
24V True Input
24V True Input
24V True Input
Analog Output
0V True Output
Relay Contact Output
Relay Contact Output
24V True Input
24V True Input
24V True Input
24V True Input
24V True Input
24V True Input
Part number
Dot
Signal Range Definition
0/24V, 100mA Actuator clear signal
0V to 10V Amplitude signal from PS
0/24V, 100mA
0/24V, 100mA System Reset
0/24V, 100mA
-10V to +10V Frequency Signal from PS
0/24V, 100mA
40V, 0.25A Contact Closure
40V, 0.25A Contact Closure
0/24V, 100mA User definable inputs. Refer to
Table 4.7 to view available
0/24V, 100mA
selections.
0/24V, 100mA
0/24V, 100mA
0/24V, 100mA
0/24V, 100mA
Colors
Red/Wht
Red/Blk/Grn
Red/Blk
Grn/Blk
Red/Blk/Wht
Blk/Wht/Blu
Blk/Wht
Red/Grn
Wht/Red/Orn
Wht/Blk
Wht/Blk/Red
Grn/Blk/Wht
Wht/Red/Blu
Blk/Wht/Grn
Wht/Blk/Grn
100-214-226 Rev. 10