Club Car Carryall 550 2019 Maintenance And Service Manual page 331

GASOLINE VEHICLE - TROUBLESHOOTING
AND ELECTRICAL SYSTEM
TEST PROCEDURE 24 – Voltage at Headlight Socket
See General Warnings on page 1-1.
NOTE: This is a voltage test.
1. If necessary, see Test Basics.
2. Inspect the wires at the light bulb socket. Make sure the wires are securely fastened to the contacts inside the
socket and that wires are installed correctly.
3. Remove the wire harness connector from the headlight bulb.
4. Set the headlight switch to ON.
5. Check for voltage across the two terminals in the connector.
WAVETEK 5XL
V
V OFF
1000
500
200 200
20
200
2 2m
200 20
m
m
200
2000
m
k
200k
20k 200
A
2k
! ! 200nA
V COM
MAX
1000 ---
FUSED
750V
485
Figure 18-24 Voltage Measurement at Headlight Socket
5.1. If there is battery voltage, check and replace the headlight bulb as necessary..
5.2. If there is no voltage, check the associated wiring, light switch, and 10-amp fuse.
2019 Carryall 550 Maintenance and Service Manual
18
Test Procedures
Page 18-39