Bosch DCI 700 Repair Instructions page 3

5.3.6 Installing the mounting
5.3.7 Installing the cover for the motor compartment and electrical
5.3.8 Final steps... . .................................................................................................................................................
5.4 Changing circuit board
5.4.1 Preparation... . ................................................................................................................................................
5.4.2 Removing the cover from the electronics
5.4.3 Removing the cover from the hydraulics
5.4.4 Removing the upper cover from the hydraulics
5.4.5 Removing circuit board
5.4.6 Installing circuit board
5.4.7 Installing the cover on the hydraulics
5.4.8 Installing the cover on the hydraulics
5.4.9 Installing the cover on the electronics
5.4.10 Final steps... . .................................................................................................................................................
6 Calibrating components... . ...........................................................................................................................
6.1 Calibrating the rail sensor
7 Troubleshooting... . ........................................................................................................................................
7.1 After the DCI 700 is switched on the screeen remains dark and the operating display does not light up on
the monitor... . ................................................................................................................................................
7.2 Touchscreen not responding... . .....................................................................................................................
7.3 The message "Disconnected" is displayed in the "DDM"
7.4 After the injector has been removed, a large amount of test oil emerges from the injection
7.5 Test oil emerges at the knurled nut on the injection chamber during the
7.6 The values for the amount of test oil are too high when injectors are
7.7 The values for the amount of test oil are too low when injectors are
7.8 No amounts of test oil are measured when injectors are
8 Software and firmware... . .............................................................................................................................
8.1 System recovery... . ........................................................................................................................................
8.2 Updating "DCI" software... . ...........................................................................................................................
8.3 Updating the firmware... . ...............................................................................................................................
Robert Bosch GmbH
panel... . ....................................................................................................................
A3... . .........................................................................................................................
compartment... . ...........................................................................
compartment... . .............................................................................
compartment... . ..................................................................
A3... . ........................................................................................................................
A3... . ..........................................................................................................................
compartment... . .................................................................................
compartment... . .................................................................................
compartment... . ................................................................................
B80... . ..................................................................................................................
compartment... . ..........................................
software... . ............................................................
test.... . ........................................
tested.... . ..........................................
tested... . ............................................
tested... . ...............................................................
1 689 975 289 | 2020-05-06
DCI 700 | 3 | en
42
44
44
44
44
45
45
46
47
49
51
52
52
53
53
53
55
55
55
55
chamber... . ..... 55
55
55
55
55
56
56
57
57