Description - Zetor COMPAX CL Series Operator's Manual

INTRODUCTION & DESCRIPTION

Description

Overall Design
The transmission case, clutch, clutch housing, engine and front axle support are bolted together to form
a rigid unit.
Front Axle and Wheels
The front axle is a 4WD, center pivot type.
The front wheel drive mechanism is incorporated as a part of the axle. The front wheel drive power is taken
from the rear-mounted transmission and transmitted to the front axle differential, where it is divided into right
and left half axles and to the final drives.
In the final drives, the transmitted speed is reduced by the axle gears for front wheel drive.
This 4WD mechanism with axle gears allows a wider range of steering and longer service life of the
mechanism.
Engine
The tractors are equipped with fuel-efficient three-cylinder engines manufactured by Yanmar.
Clutch and Transmission
A single-plate dry clutch is used in these tractors.
Tractors with IPTO (independent power take-off) are equipped with a hydraulic clutch assembly.
The transmission has six forward gears and two reverse gears with the High-Low selector lever.
Brakes Brakes
Zetor tractors are equipped with disc brakes controlled by a foot pedal. There is a parking brake lever
installed for parking.
Rear Axle and Wheels
It is mounted on ball bearings and is enclosed in a removable housing that is attached to the transmission
case.
The rims and discs, assembled with the rear tires, are attached to the mounting points of the rear axle.
Hydraulic System and Hitches
Zetor tractors are equipped with active (i.e. the system is running) independent systems. A three-point hitch
may be used for Type 1 (N) implement category.
Steering
Steering consists of a hydrostatic power steering system that has a hydraulic cylinder and a single acting
hydraulic pump.
Electrical System
A 12 V battery is installed to start the motor using the starter.
The electrical system includes a horn, headlights, turn signal lights, tachometer, hour meter, brake lights,
instrument lighting, hazard warning lights, generator or alternator, and a fuse box.
12