Transmission Oil Level Inspection; Transmission Oil Replacement - Yamaha DT125RE 2005 Service Manual

TRANSMISSION OIL LEVEL INSPECTION/

TRANSMISSION OIL REPLACEMENT

2
3
1
2
TRANSMISSION OIL LEVEL INSPECTION
1. Inspect:
• transmission oil level
Oil level low
Transmission oil level steps:
• Place the machine on a level surface.
• Warm up the engine for several minutes and
stop it.
• Visually check the oil level through the level
window
NOTE:
• Check the oil level just one minute after
stopping the engine.
• The oil should e confirmed between maxi-
mum
• If the oil level is lower, add sufficient oil to
raise it to the proper level.
Recommended oil:
• Do not add any chemical additives.
Transmission oil also lubricates the clutch
and additives could cause clutch slippage.
• Be sure no foreign material enters the
crankcase.
TRANSMISSION OIL REPLACEMENT
1. Warm up the engine for several minutes.
2. Place a container under the engine.
1
3. Remove:
• oil filler cap
• drain pulg
drain transmission oil.
2
NOTE:
Drain the transmission oil with the motorcycle
slightly inclined to the right.
4. Inspect:
• gasket (Drain plug)
• O-Ring (oil filter cap)
Damage
3-11
CHK
ADJ
Add sufficient oil
.
and minimum marks.
SAE10W30 Type SE Motor Oil
Replace