Safety Precautions; Air Conditioning System; Chemical Handling And Storage - Aston Martin DB7 Workshop Manual

Introduction / ^ r " ^ ^ ^ ^ ^ 3 ^ '"'P ?
Safety Precautions L — ^ ^^—^
Safety Precautions "
All service workshops are a source of potential danger and repair work should only be performed by technically
trained staff following the procedures in this manual. A safety conscious approach to the performance of all service
procedures must be observed at all times. Statutory requirements governing all aspects of health and safety at work
including directives for the proper use of materials and equipment must be implemented.
The following contains a list of particular safety precautions which should be observed; it is not intended to be
exhaustive.
Air Conditioning System
Do not disconnect any air conditioning refrigerant system pipes unless trained and instructed to do so. The refrigerant
used can cause blindness if allowed to contact your eyes.
Chemical Handling and Storage
Chemicalsusedintheservicingofmotorvehiclesincludeacids,adhesives, antifreeze, brake fluids, coolants, grease,
oil, paint, resin and solvents. Exposure to certain chemicals through direct contact or inhalation can be fatal.
Potential hazards may also be present through the incorrect use, storage and handling of chemicals causing a fire
risk. The following precautions should be observed.
1. Strictly adhere to handling and safety information found on containers and labels.
2. Do not store chemicals in unlabelled or incorrectly labelled containers.
3. Containers used for storing chemicals should not be left open; there is a risk of spilling, or evaporation of fumes
which may be inflammable or toxic.
4. Do not mix chemicals unless instructed to do so following manufacturers guidelines.
5. Do not inhale chemical materials to determine identity, they may be toxic.
6. Do not use petrol, kerosene, diesel fuel, gas oil, thinners or solvents for washing skin.
7. Containers whose capacity is over 25 litres (5 gallons) require a bund wall in order to contain spillages.
8. Chemicals based on solvents such as paint should not be sprayed in a confined space; work areas used for
such operations should be well ventilated and fume extraction equipment should be utilised.
9. Ensure that adequate ventilation is provided when volatile de-greasing agents are being used.
WARNING: Fume extraction equipment must be in operation when solvents are used e.g. trichloroethane, white
spirit, SBP3, methylene chloride, perchlorethylene.
WARNING: Do not smoke in the vicinity of volatile de-greasing agents.
10. Avoid splashing the skin, eyes and clothing.
11. Clean chemicals from the skin and clothing as soon as possible after soiling.
12. Wear protective clothing such as goggles, non porous gloves and apron when hand I ing battery acid and other
corrosive and toxic substances.
iv April 1997