Ignition Charging Device For The Ignition; Battery Caution; Instruction For Filling Electrolyte - TGB Hornet 50 Service Manual

3-4-1 IGNITION CHARGING DEVICE FOR THE IGNITION

B. Battery : The Battery is the type of Water-Adding Free.

1. Battery Caution:

1. The electrolyte contains sulphuric acid is poisonous. avoid to contact
with eye, skin and clothes. Immediately wash with abundant water
and call a doctor at once in case of contact with the eyes or skin.
Immediately drink beaten eggs or vegetable oil, call a doctor at once
in case of drink.
2. batteries release explosive gases, prohibit to closed to sparks,flames
or cigarettes.
3. When charging or using the battery in a closed location, make sure
that ventilation is good.
4. Keep off children hands.
2. Instruction for Filling Electrolyte (For Water-adding Free Battery)
1. Remove the Aluminum Seal
on the filling hole of
battery.
2. Remove the cover bar and
battery sealing bolt.
3. Insert the filling hole of electrolyte
container into the filling hole of
battery. Try not to spillage it.
4. There are three pipes on each
side. Tap the bottom of container
lightly when the electrolyte bubbles.
Pulling it out will be unnecessary.
5. Remove the container from the
battery after all electrolyte
is filled into battery.
6. Insert the fixing plug in the
filling hole of battery and
press the fixing plug until
it is not higher than the top
of cover.
Note : The Battery is completely ready to use, thus do not
remove the Aluminum Seal on the closed filling hole until it
is to be used. Electrolyte, except those specified, is
absolutely forbidden. While filling the electrolyte, only
regulated volume of electrolyte can be adopted. The seal
plug should not be removed after the electrolyte is added.
36