Steering Column Disassembly - Club Car 2008 Turf Maintenance And Service Manual

9
STEERING AND FRONT SUSPENSION
Steering Column Removal, Continued:
3. Remove the center dash panel (Figure 9-4, Page 9-4).
3.1. Remove the plastic cap (1) covering the mounting screw (2) on each side of the center dash panel
(3) (Figure 9-4, Page 9-4).
3.2. Loosen, but do not remove, the screw (2) on each side of the center dash panel (3).
3.3. Insert screwdriver at the top center of the dash between dash and cowl brace. Gently pry center
dash out slightly from under edge of cowl brace.
3.4. Pull center dash out from the frame and disconnect the wires from the electrical components
mounted on the dash panel. Do not allow wires to touch. See following NOTE.
3.5. Take care to prevent key switch terminals and wires from touching the metal frame around the
dash.
3.6. Slide center dash panel up the steering column.
4. Remove the driver-side dash pocket.
4.1. Remove the flange lock screw from the top of the dash pocket.
4.2. Drill out the two pop rivets holding the dash pocket in place.
4.3. Slide dash pocket out of vehicle
5. Remove the upper bolt (2) and lock washer (3) from the universal joint (Figure 9-3, Page 9-3).
6. Remove the nuts (9), bolts (8 and 10), and washers (7 and 11) from the steering column mount (4 and
5) (Figure 9-3, Page 9-3).
7. Remove the steering column from the vehicle.

STEERING COLUMN DISASSEMBLY

1. Remove bolts (6) and mounts (4 and 5) from steering column. Remove boot (12) (Figure 9-3, Page 9-3).
Page 9-4 2008 Turf/Carryall Vehicle Maintenance and Service Manual
3
Figure 9-4 Dash Removal
.
Steering Column
2
1