Access Door - Turf 6 And Carryall 6; Access Door Removal; Access Door Installation; Side Door - Turf 6 And Carryall 6 - Club Car 2008 Turf Maintenance And Service Manual

4
BODY AND TRIM
ACCESS DOOR – TURF 6 AND CARRYALL 6
See General Warning, Section 1, Page 1-1.

ACCESS DOOR REMOVAL

1. Raise levers on left and right hand door latches (11), rotate them 180 degrees and open access door.
Rest door against seat back support panel (Figure 4-4, Page 4-9).
2. Remove three lock nuts (17) and bolts (16) from access door side of hinge.
3. Remove access door from cargo bed.

ACCESS DOOR INSTALLATION

1. Install access door in the reverse order of removal (Figure 4-4, Page 4-9).
2. Tighten nuts (17) to 8 ft-lb (10.8 N·m).
3. Close access door and secure both door latches (11).
SIDE DOOR – TURF 6 AND CARRYALL 6
See General Warning, Section 1, Page 1-1.

SIDE DOOR REMOVAL

1. Lift door latch lever (27), rotate 180 degrees, and open side door (Figure 4-4, Page 4-9).
2. Remove two 1/4 x 5/8 bolts (26) and lock nuts (25) from door hinge.
3. Remove side door from rear body.

SIDE DOOR INSTALLATION

1. Install side doors in the reverse order of removal.
2. Tighten bolts to 35 in-lb (3.9 N·m). See following NOTE.
NOTE: When installing side door and hinge assembly, make sure mounting bolts are positioned so that when
side door is closed, the mounting bolts do not prevent the side door from being closed all the way.

REAR FENDER

See General Warning, Section 1, Page 1-1.

REAR FENDER REMOVAL

Turf 6, Carryall 6 and other vehicles with taillights:
1. Remove taillight assembly.
1.1. Remove the two screws (14) that secure taillight (15) to the rear fender (Figure 4-6, Page 4-12).
1.2. Disconnect the three taillight wires.
Page 4-10 2008 Turf/Carryall Vehicle Maintenance and Service Manual
Access Door – Turf 6 and Carryall 6