Section 7 - Wheels And Tires; General Information; Wheels; Wheel Removal - Club Car 2008 Turf Maintenance And Service Manual

SECTION 7 – WHEELS AND TIRES
ý
DANGER
• See General Warning, Section 1, Page 1-1.
ý
WARNING
• See General Warning, Section 1, Page 1-1.

GENERAL INFORMATION

Maximum tire life and good vehicle handling qualities are directly related to proper wheel and tire care.
• Keep tires properly inflated as follows:
- 16-18 psi (1.10-1.24 Bars) for Turf 1 and Carryall 1 gasoline vehicles
- 18-20 psi (1.24-1.38 Bars) for Turf 1 and Carryall 1 electric vehicles
- 30-34 psi (2.07-2.34 Bars) for all other vehicles.
• Keep lug nuts properly tightened.
• Keep the front end properly aligned and adjusted.

WHEELS

See General Warning, Section 1, Page 1-1.

WHEEL REMOVAL

1. Slightly loosen the lug nuts on the wheel to be removed.
2. Raise the end of the vehicle from which the wheel is to be removed. Make sure the wheels are off the
ground. See WARNING "Lift only one end of the vehicle..." in General Warning, Section 1,
Page 1-1.
3. Remove the lug nuts and remove the wheel.

WHEEL INSTALLATION

1. Install wheel(s), and use a crisscross pattern to tighten the lug nuts until they are snug.
2. Lower the vehicle, and use a crisscross pattern finish tightening the lug nuts to 55 ft-lb (74.6 N·m).
2008 Turf/Carryall Vehicle Maintenance and Service Manual
7
Page 7-1