Regal 42SC Owner's Manual page 302

TYPICAL MAINTENANCE SCHEDULE-VOLVO IPS DIESEL ENGINE
WARNING
!
AVOID PERSONAL INJURY
BEFORE PERFORMING ANY MAINTENANCE
WORK READ AND UNDERSTAND THE
OWNER'S MANUAL. IT CONTAINS THE
RECOMMENDED PROCEDURES.
NOTICE
MAINTENANCE POINTS MARKED WITH A
* MUST BE PERFORMED BY AN
AUTHORIZED VOLVO PENTA DEALER.
The IPS propulsion package is designed to provide
many years of reliability and satisfaction. To keep the
unit running at peak performance a service maintenance
schedule is recommended. Only basic information is conveyed
here. Refer to the Volvo operation manual for detailed information
or contact a Volvo authorized service center.
BEFORE EACH OUTING OR DAILY:
♦ Engine & Sump- General inspection
♦ Engine Oil- Check Level
♦ Coolant- Check Level
♦ Leaks- Check After Starting Engines
♦ Drive Unit Oil- Check Level
EVERY 14 DAYS
♦ Drive Belts- Wear Check
♦ Seawater Filter- Clean
♦ Battery- Check Electrolyte Level
(1) Oil change intervals vary, depending on oil grade and
sulfur content of fuel.
Cosmetic Care & Maintenance
EVERY 100-200 HOURS OR YEARLY
♦ Engine Oil- Change (1)
♦ Engine OIl Filter- Change (2)
EVERY 200 HOURS OR YEARLY
♦ Crankcase Ventilation Filter- Change
♦ Air Filter- Change
♦ Drive Belts- Check Tension
♦ Compressor- Check Oil Level
♦ Seawater Pump- Check Impeller
♦ Sacrifi cial Anodes- Check Air Cooler, Heat Exchanger
♦ Fuel fi lters- Change
♦ Paint- Touch-Up As Needed
* Exhaust & Cooling Hoses
* Hose Clamps- Tighten
* EVC System- Check With Diagnostic Equipment
EVERY 400 HOURS OR YEARLY
♦ Drive Unit- Oil & Fllter- Change
♦ Drive Unit- Corrosion Protection- Check Anodes
EVERY SECOND YEAR
♦ Coolant- Change
EVERY 400 HOURS OR YEARLY
♦ Drive Unit- Oil & Fllter- Change
♦ Drive Unit- Wear Check Propeller & Steering
EVERY 600 HOURS OR ONCE EVERY 5 YEARS
♦ Turbocharger- Inspect & Clean
♦ Drive Unit- Wear Check Propeller & Steering
(2) Always change the oil fi lter with each oil change.
57