Safety Instructions; General Instructions; Special Instructions - Husqvarna Rider ProFlex 21 II Workshop Manual

For Husqvarna Parts Call 606-678-9623 or 606-561-4983

Safety Instructions

General Instructions

This workshop manual is written for personnel with general knowledge about the repair and service of riders.
The workshop where the rider is to be repaired must be equipped with safety equipment in accordance with
local bylaws.
No one may repair the rider unless they have read and understood the content of this workshop manual.
The machine is tested and approved only with the equipment originally provided or recommended by the
manufacturer.
This workshop manual contains the following boxes in relevant places.
!
WARNING!
The warning box warns of the risk of
personal injury if the instructions are not
followed.
IMPORTANT INFORMATION
This box warns of material damage if the
instructions are not followed.

Special Instructions

The fuel used in the rider has the following hazardous properties:
• The fluid and its vapour are poisonous.
• Can cause eye and skin irritation.
• Can cause breathing problems.
• Is highly inflammable.
When using compressed air, do not direct the jet towards the body. Air can penetrate into the blood
circulation system, which entails mortal danger.
Use eye protection when working with tensioned springs.
Wear protective earplugs or earmuffs when test running.
After test running, do not touch the muffler until it has cooled. Risk for burns. This is especially true if the
rider is equipped with a catalytic converter. The coatings on and in the catalytic converter element are
hazardous to ingest. Use protective gloves when working with the converter/muffler.
The blades are sharp and can cause cuts and gashes. Use protective gloves when handling the blades.
Use eye protection when working with the cutting unit. The belt tensioning spring can break, fly off, and
cause personal injury.
Use eye protection when working with the battery with the plugs removed. Be especially careful when
handling battery acid. Acid on the skin can cause serious corrosive injuries. In the event of spillage on the
skin wash immediately with water.
Acid in the eyes can cause blindness; contact a doctor immediately.
Be careful when servicing the battery. Explosive gases form in the battery. Never perform maintenance on
the battery while smoking or in the vicinity of open flames or sparks. This can cause the battery to explode
and cause serious injuries.
IMPORTANT INFORMATION
Waste oil and old filters shall be handled as hazardous waste.
2
English-
SAFETY INSTRUCTIONS
www.mymowerparts.com