Club Car Carryall 500 2015 Maintenance And Service Manual page 299

TROUBLESHOOTING AND ELECTRICAL
SYSTEM: PEDAL-START GAS VEHICLE
18-PIN CONNECTOR (GRAY AND BLACK): A. ECU SIDE OF CONNECTOR B. WIRE ENTRY SIDE OF CONNECTOR
PIN CONNECTOR
FUNCTION
I.D. COLOR
3 Black Ignition OFF Input
7 Black Low Oil Sensor Input Resistance: ECU Black Pin 7 (Yellow) and Ground
8 Black Connected Car Link
9 Black B+ Input
Ground for ECU
10 Black
Power
Diagnosis (low oil)
11 Black
Lamp Control
12 Black Foot Input
Ground for ECU
18 Black
Housing
A
TEST TYPE & PROBE BETWEEN LOCATIONS
Continuity: ECU Black Pin 3 (Black/White) and Ground
Voltage: ECU Black Pin 8 (Blue/White) and Ground
Voltage: ECU Black Pin 9 (Red) and ECU Black Pin 10
(Black)
Continuity: ECU Black Pin 10 (Black) and Ground
Voltage: ECU Black Pin 10 (Black) and Battery (+)
Terminal
Voltage: ECU Black Pin 11 (Yellow/Black) and Ground
Continuity: ECU Black Pin 12 (White/Black) and Black
Pin 18 (Black)
Continuity: ECU Black Pin 18 (Black) and Ground
Voltage: ECU Black Pin 18 (Black) and Battery (+)
Terminal
2015 Carryall 500 and 700 Maintenance and Service Manual
Test Procedures
B
TEST RESULT
Meter should beep
Meter should NOT
beep
Approx.
2.3 kOhms
11.8 volts
Battery Voltage
Meter should beep
–Battery Voltage
Less than
1 Volt initially.
7 to 8 volts after
lamp is OFF.
Meter should beep
Infinity
Accel. Pedal
Meter should beep
–Battery Voltage
18
CONDITION
Key OFF
Key ON
Key OFF
Key ON
Key ON
Key OFF
Key OFF
Key ON
Key OFF with:
UP
Accel. Pedal
DOWN
Key OFF
Key OFF
Page 18-25