Club Car Carryall 500 2015 Maintenance And Service Manual page 279

TROUBLESHOOTING AND ELECTRICAL
SYSTEM: PEDAL-START GAS VEHICLE
TROUBLESHOOTING GUIDE
SYMPTOM
Engine turns but fails to start.
Engine overheats.
Engine pre-ignites.
Loss of engine power.
TABLE CONTINUED ON NEXT PAGE
POSSIBLE CAUSES
Fuel tank is empty
Fuel line or filter clogged
Fouled spark plug
Spark plug wire damaged or loose
Loose wire connection at ignition coil
Ignition coil failed
Kill circuit grounded
Fuel pump malfunction or failure
Fan screen is partially blocked or plugged
Governor is improperly adjusted
Excessive back pressure in exhaust
Fuel/air mixture is too lean; check EFI
Overloading
Poor quality engine oil
Excessive carbon deposits on piston head or
in combustion chamber
Spark plug heat range is incorrect
Unsuitable or contaminated fuel
Exhaust valve is restricted with carbon deposit
Muffler or exhaust pipe restricted with carbon
or other substance
Ignition coil failed
Air filter is dirty or clogged
Governor is improperly adjusted
Throttle linkage out of adjustment
Low cylinder compression
Spark plug failed
Restricted fuel flow
Torque converter is not backshifting properly
2015 Carryall 500 and 700 Maintenance and Service Manual
Troubleshooting Guide
CORRECTIVE ACTION
Section 23 — Fuel System: Gasoline Vehicles
Section 23 — Fuel System: Gasoline Vehicles
Section 22 — Engine (Subaru EX40)
Section 22 — Engine (Subaru EX40)
Test Procedures 15 – Ignition Spark and 16
– Ignition Coil
Test Procedures 15 – Ignition Spark and 16
– Ignition Coil
Test Procedures 14 – Kill Limit Switch –
Pedal-Start Vehicles Only and 6 – Key Switch
(Engine Kill Circuit)
Section 23 — Fuel System: Gasoline Vehicles
Section 22 — Engine (Subaru EX40)
Section 23 — Fuel System: Gasoline Vehicles
Check and clean or replace
Section 23 — Fuel System: Gasoline Vehicles
Reduce to rated load
Replace
Section 22 — Engine (Subaru EX40)
Section 22 — Engine (Subaru EX40)
Section 23 — Fuel System: Gasoline Vehicles
Section 22 — Engine (Subaru EX40)
Section 24 — Exhaust System: Gasoline
Vehicles
Test Procedures 15 – Ignition Spark and 16
– Ignition Coil
Section 23 — Fuel System: Gasoline Vehicles
Section 23 — Fuel System: Gasoline Vehicles
Section 23 — Fuel System: Gasoline Vehicles
Section 22 — Engine (Subaru EX40)
Section 22 — Engine (Subaru EX40)
Section 23 — Fuel System: Gasoline Vehicles
Section 25 — Clutches: Gasoline Vehicles
18
Page 18-5