Bandit INTIMIDATOR 15XP/1390 Operating & Parts Manual page 52

MODEL 15XP/1390
CHIPPER HOOD ENGINE DISABLE PLUG OPERATION
This chipper hood engine disable plug is installed for safety purposes. It is designed to shut down the
engine if the hood pin is not properly in place holding the chipper hood in the closed position. The system
must be correctly maintained and operative at all times. If the disable plug is not correctly installed the engine
will not start or run.
The chipper hood engine disable plug is located on top of the chipper hood. The chipper hood engine
disable plug is made up of two parts: an electric socket and a disable plug. The electric socket is bolted to
the chipper hood engine disable plug mount bracket and the disable plug is attached by a cable to the hood
pin.
If the disable plug is not properly installed then the engine will not start or run. If the disable plug becomes
disconnected while the chipper engine is running the engine will be shut down or be disabled from running.
This is for safety purposes, to ensure that the hood pin is not removed and the chipper hood is not opened
while the engine is running.
The chipper hood engine disable plug is wired to shut down the chipper engine. When the disable plug is
pulled out of the electric socket the electric circuit is broken, disabling the engine.
NOTICE
The engine disable plug has a circuit fuse. If the engine will not start or run, check the fuse fi rst before
consulting the engine manufacturer's manual. Circuit fuse locations: Caterpillar / Perkins - located at the
"BATT" wire near the ignition switch, Cummins - located by engine manufacturer near the starter (wires
labeled "POW"), John Deere - located by engine manufacturer "Short Stop" circuit breaker by the ignition
switch on the instrument panel or fuse by the ECM, and Deutz, Hatz, Honda, Kohler, and Robin - located at
the battery post on the starter.
ELECTRIC
SOCKET
PADLOCK
HOOD DOOR
DRUM CHIPPER
Copyright 9/18
CABLE (TIGHT WHEN
PLUGGED IN AND
PADLOCK IS IN!)
DISABLE PLUG
DISABLE PLUG
HOOD PIN
HOOD PIN
CHAIN
36
CONTROLS
PADLOCK
ELECTRIC
SOCKET
CHIPPER HOOD
DISC CHIPPER
Bandit