Table of Contents
Advertisement
GASOLINE VEHICLE - FUEL SYSTEM
FUEL TANK
See General Warnings on page 1-2.
GENERAL INFORMATION
The vehicle is equipped with a high impact, plastic fuel tank.
WARNING
• If the fuel tank is damaged, replace it. Do not attempt to repair it. See the following tank removal
and disposal procedure.
CAUTION
• Add only unleaded fuel to the tank. Do not put oil in the fuel tank.
NOTE: This gasoline vehicle complies with the California Air Resources Board (CARB) and EPA evaporative
emissions regulations when equipped with SAEJ30R9 1/4 in (6.3 mm) fuel vent hose and 3/16 in (4.78 mm)
fuel vent hose. To remain in compliance with California and EPA regulations, replace any fuel vent hose on
this vehicle with Club Car fuel vent hoses or equivalent.
FUEL TANK REMOVAL
1.
Place the Forward/Reverse handle in the NEUTRAL position, chock the wheels, and the neutral lockout switch in
the MAINTENANCE position.
2.
Turn key switch to OFF position and remove key.
3.
Disconnect battery.
See Disconnecting the Battery- Gasoline Vehicles on page 1-3.
4.
Clean the top of the fuel tank (10) and fuel pump module (1) (Figure 21-15, Page 21-22).
5.
Remove gas cap and siphon all fuel from tank into an approved container. See following DANGER and
WARNING.
DANGER
• Gasoline – Flammable! Explosive! Do not smoke. Keep sparks and flames away from the vehicle and
service area. Service only in a well-ventilated area.
WARNING
• Do not attempt to siphon fuel using a hose that does not have a built-in suction device.
• Do not attempt to siphon fuel using your mouth.
6.
Disconnect wire harness plug (2) from fuel pump module (1).
7.
Disconnect vent hose from fuel tank vent (11).
8.
Disconnect the fuel line (3) from the fuel pump module (1) and drain into an appropriate container. See Fuel Line
Removal on page 21-17. See following WARNING.
2019 Precedent Villager 2 Maintenance and Service Manual
21
Fuel Tank
Page 21-23
Advertisement
Table of Contents
Troubleshooting
