Maintenance; General Instructions - Belarus 3522.5 Operator's Manual

6. Maintenance

6.1 General instructions

ATTENTION: ALL ENGINE MAINTENANCE SERVICES, INCLUDING DAILY
MAINTENANCE SERVICES ARE SET FORTH IN THE ENGINE TCD 7.8 L06 OPERA-
TION MANUAL ATTACHED TO YOUR TRACTOR! IN THE PRESENT SECTION OF THE
OPERATION MANUAL ONLY MAINTENANCE SERVICES FOR EXTERIOR PARTS OF
WATER COOLING, SUPERCHARGED AIR COOLING, ENGINE AIR CLEANING SYS-
TEMS DEVELOPED AT MTW!
Maintenance services (MS) is needed to maintain the tractor in operable state dur-
ing operation. Non compliance with the specified intervals and bad quality of MS may re-
sult in reduction of tractor life, increase of failure number, engine power loss and increase
in expenses for tractor operation. Operator must carry out daily inspection of the tractor,
excluding fasteners torque-retention loss, fuel, liquid, and oil leakage, dirt and other depos-
its accumulation, which can cause operating troubles, ignition or accidents.
Notes about performance of maintenance services shall be made in the tractor ser-
vice book.
Comply with storage precautions and waste recovery rules. Never discharge used
liquid on the ground. Use special tanks for safe storage of waste.
WARNING: DURING CARRYING OUT OF MAINTENANCE AND REPAIR SER-
VICES COMPLY WITH SAFETY PRECAUTIONS, LISTED IN SUBSECTION 6.5
"SAFETY PRECAUTIONS IN THE COURSE OF MAINTENANCE AND REPAIR SER-
VICES"!
ATTENTION: IF THERE IS NO SPECIAL INSTRUCTIONS, BEFORE STARTING
ANY MAINTENANCE OR ADJUSTMENT SERVICES, ETC., STOP THE ENGINE AND
ENGAGE PARKING BREAKS. IN CASE SAFETY GUARDS AND COVERS ARE OFF,
ENSURE THEY ARE MOUNTED BACK AFTER MAINTENANCE SERVICES HAS COM-
PLETED, BEFORE YOU START OPERATING THE TRACTOR!
During hydraulic lift system, steering, and transmission line hydraulic system main-
tenance services, oil change and filters replacement intervals should be observed. It is not
allowed to use oil, not specified in the tractor operation manual for filling (refilling).
Before refilling and replacement of filter cartridges clean filler plugs, necks, and
caps, and adjoining surfaces from dirt and dust. During replacement of filter cartridges,
wash the internal surfaces of filter housings and caps with the diesel fuel.
When the tractor is coupled with hydraulically-operated implements, clean clutches,
couplings, adapting pipes and other connecting parts of the implement and the tractor
thoroughly.
In case the hydraulic system is operated with hydraulically-operated implements
filled with oil origin of which is unknown, the oil in the implement must be replaced by the
oil, primed into the tractor hydraulic lift system.
Purity of the hydraulic system oil ensures its fail-safe operation.
264
https://tractormanualz.com/
3522.5-0000010 OM