Fire Safety Measures - Belarus 3522.5 Operator's Manual

Before lifting up and down a hinged agricultural implement and also when turning
the tractor make sure there is no danger of catching somebody or stumbling on the hurdle.
The mounted and semi-mounted machine is to be lowered down into its operating
position and lifted up into the hauling position only with a straight-line motion of the as-
sembly unit.
To avoid breakdown of the tractor or the agricultural implement, drive and turn the
tractor assembly with the agricultural implement uplifted only after you make sure the front
and rear PTOs are disengaged.
Linking and hinging the agricultural machines and implements on the tractor the
rear operator shall stay at a safety distance until the operation is fully stopped. The linkage
(hinge) shall be started only after the tractor operator gives a command.
Linking the machine cardan shaft to the RPTO, disengage the RPTO, stop the trac-
tor by means of the parking brake and stop the engine.
After disconnecting the machines driven by the rear or the front RPTO, remove car-
dan drives and cover the PTO end extensions with protective caps.
Cardan shafts, transferring torque from the front and rear PTOs of the tractor to the
implement working units shall be safeguarded.
Operating with stationary machines, driven by the front and rear PTOs, always en-
gage the parking brake and lock the rear wheels at the front and at the back. Make sure
the machine is securely fixed.
Make sure you mounted the safeguards of the front and rear PTOs and, if the PTO
is not used, put back the cap of the PTO shaft end extension.
Do not wear loose clothes when working with the front and rear PTOs or near rotat-
ing equipment.
To avoid breakdown of the tractor or the agricultural machine, turning the tractor as-
sembly is possible only after the working units of the machine have been fully raised from
the ground.
When the tractor assemblies are operating in column, they shall have an interval of
30 m between each other.
Avoid sharp turns when fully loaded and at a high speed of travel.
Depending on operation conditions use natural ventilation of the cab or the unit of
air cooling and heating.
During tractor operation the operator shall use standard means of protection for hearing
organs.
In case the tractor assembly is operated or is driven in an area of power transmis-
sion lines, a distance between the top of the tractor assembly and wires shall conform to
table 4.6.
Table 4.6
Line voltage, кV, up to
Horizontal distance, m, not less than
Vertical distance, m, not less than

4.3.2 Fire safety measures

The tractor shall be equipped with fire fighting equipment, i.e. a shovel and a fire
extinguisher. Operating the tractor without fire fighting equipment is forbidden.
Never fuel the tractor with the engine running.
Do not smoke when fueling in the tractor.
Do not fuel the tank to the max. Leave some volume for fuel to expand.
Never add petrol or mixtures to engine fuel. This combination may create increased
danger of inflammation or explosion.
Places for tractor parking, storing of fuel and lubricants shall have a plowed around
11
1,5
1
234
https://tractormanualz.com/
3522.5-0000010 OM
20-25 110 154-220
2 4 6
2 3 4
330-500
9
6