Lubricants, Fuel And Coolant - Kubota RTV520 Operator's Manual

LUBRICANTS, FUEL AND COOLANT

LUBRICANTS, FUEL AND COOLANT
No. Locations
1 Fuel
Coolant (with reserve
2
tank)
Filter ex-
changed
Engine
3
crankcase
Filter not
exchanged
4 Transmission case
5 Front axle case
Brake fluid
6
(fluid tank and lines)
*1 Oil amount when the oil level is at the upper level of the oil level gauge.
*2 KUBOTA UDT or SUPER UDT-2 fluid － KUBOTA original transmission hydraulic fluid
Greasing
VHT link
Battery terminal
Cargo bed pivot
Parking brake lever pivot
Range gear shift lever pivot
4WD lever pivot
Differential lock lever pivot
Bypass link
Fuel:
• Gasohol (up to 10% ethyl alcohol, 90% unleaded gasoline by volume) is approved for the engine. Other gasoline
and alcohol blends are not approved.
Engine oil:
• Oil used in the engine should have an American Petroleum Institute (API) service classification and proper SAE
engine oil according to the ambient temperatures as shown previous:
Transmission Oil:
To complete lubrication of the transmission, it is important that a multi-grade transmission fluid is used in this system.
We recommend the use of KUBOTA UDT or SUPER UDT-2 fluid for optimum protection and performance.
Consult your local KUBOTA Dealer for further detail.
Do not mix different brands or grades.
Brake fluid:
Always use KUBOTA DOT3 GENUINE BRAKE FLUID from a sealed container. If it is not available, you should use
only DOT3 fluid as a temporary replacement from a sealed container.
However, the use of any non-Kubota brake fluid can cause corrosion and decrease the life of the system.
Have the brake system flushed and refilled with KUBOTA DOT3 GENUINE BRAKE FLUID as soon as possible.
• Indicated capacities of water and oil are manufacturer's estimate.
RTV520
Capacity
19.2 L (5.1 U.S.gals.)
2.4 L (2.5 U.S.qts.)
*1
1.35 L (1.43 U.S.qts.)
*1
1.2 L (1.27 U.S.qts.)
9.0 L (2.4 U.S.gals.)
0.21 L (0.22 U.S.qts.)
0.2 L (0.21 U.S.qts.)
No. of greasing points
1
2
2
2
1
1
1
1
Lubricants
• Automobile unleaded or regular gasoline
• Unleaded gasoline 87 octane or higher
Fresh clean water with antifreeze
• Engine oil: API Service
Classification SH or higher
Above 0 ℃ (32 ℉)...SAE10W-30
Above -18 ℃ to 0 ℃ (0 ℉ to 32 ℉)...SAE5W-20, 5W-30 or 10W-30
Below -18 ℃ (0 ℉)...SAE5W-20 or 5W-30
For U.S.A market: KUBOTA SUPER UDT2 fluid
For Canada market: Premium UDT fluid
For other than the above: KUBOTA UDT or SUPER UDT-2 fluid
KUBOTA DOT3 GENUINE BRAKE FLUID
Capacity
Until grease overflows
Moderate amount
MAINTENANCE
*2
*2
*2
Type of grease
Multipurpose grease
NLGI-2 or NLGI-1 (GC-LB)
Spray type grease
51