Fuel Handling Precautions; Fire Prevention Precautions - Progressive Turf Equipment Slope-Pro Operator's Manual

Safety Precautions

Fuel Handling Precautions

Gasoline and its vapors are extremely flammable and
explosive. Fire or explosion can cause severe burns or death.
▪
Turn engine OFF when refueling.
▪
Refill one fuel tank at a time. Remove it from the machine to refill.
Replace the empty tank with a full one and properly secure the
tank.
▪
Refuel in a well-ventilated area or outdoors.
▪
Do not smoke while refueling.
▪ Do not overfill fuel tanks. Do not fill past "full" mark on fuel tank.
▪
Keep gasoline away from sparks, open flames, or other ignition
sources.
▪
Check fuel lines, tank caps, hoses and fittings frequently for cracks
or leaks. Replace as necessary.
▪
Never operate the machine without the fuel tank tie-down straps in
place.
▪
Keep the fuel tank cap installed and tight. Should the fuel tank cap
be lost, replace it only with the original manufacturer's approved
cap.
▪
Clean up spilled gasoline immediately. Allow it to evaporate before
starting engine.
▪
Do not operate the machine without muffler, air cleaner, fuel cap or
fuel tank vent lines in place.
▪
Do not crank the engine with the spark plug removed.

Fire Prevention Precautions

▪
Prevent combustible debris from collecting on the machine. This
debris by itself may not cause a fire, however, when mixed with
fuel, oil, or grease in a hot or confined space, the danger of fire
increases dramatically.
▪
Do not operate machine in areas with fire or explosive risk
▪
Check to make sure gasoline and hydraulic hoses are not worn or
damaged, and are routed to avoid chafing.
▪
Inspect wiring for chafing, breakage, and any routing condition that
could expose wiring to damage. This is especially important for
positive electrical wires that could make contact with the frame
(ground). Pay special attention to the cables from the battery to the
starter.
▪
When reconnecting wires, it is important to connect, route and
secure them so they are protected from damage and wear. They
must not be routed in contact with fuel or oil hoses.
10
Operator's Manual
®
Slope-Pro