Maintenance Table; Transmission Oil - Malaguti MALBO Line Service Manual

MAINTENANCE TABLE

NOTE - Maintenance operations should be performed more frequently if the vehicle is used in rainy weather, in dusty
places or on rough terrain.
Due to their simplicity, checks featuring an asterisk CAN also be carried out by technicians not author-
ised by MALBO Line or MALAGUTI, but under their direct responsibility.

TRANSMISSION OIL

Checking level/topping up every 5,000 km/3,120
miles or 12 months
1 - Park the vehicle on a level surface on its centre
stand.
2 - Unscrew the dipstick (A-Fig. 19)
3 - If necessary, top up until it overflows.
4 - Refit and tighten the oil filling screw. Recommended
oil: Q8 T35 - 80W
Renew after the first 500/1,000 km (312/624 mi) and
every 10,000 km (6,240 mi) or 24 months
1 - Park the vehicle on a level surface on its centre
stand.
2 - Put a container under the drain cap.
3 - Remove the oil filler screw (A-Fig. 19).
4 - Unscrew the oil drainage screw (B-Fig. 19) and
drain out the entire oil content.
5 - Clean the drainage screw and refit it.
6 - Fill with new oil of the recommended type until you
notice oil overflowing.
Recommended oil: Q8 T35 - 80W
Capacity: 120 cc.
7 - Refit the oil filler screw and wrench in place.
Perform this operation with the engine off and
cold.
Prevent foreign matters from getting into trans-
mission crankcase during checks or oil chang-
es. Prevent oil dripping on tires or wheels.
8 03/10
A
B
Fig. 19