Scheduled Maintenance Table; Routine Maintenance Table - MOTO GUZZI Stelvio 1200 4V Service Manual

STELVIO 4V - 1200

Scheduled maintenance table

NOTE
CARRY OUT MAINTENANCE OPERATIONS AT HALF THE INTERVALS SPECIFIED IF THE VE-
HICLE IS USED IN PARTICULAR RAINY OR DUSTY CONDITIONS, OFF ROAD OR FOR TRACK
USE.
NOTE
THE TIMES LISTED ON THE SCHEDULED MAINTENANCE TABLE INCLUDE TIME DEDICATED
TO MANAGEMENT ACTIVITIES.
I: INSPECT AND CLEAN, ADJUST, LUBRICATE OR REPLACE IF NECESSARY
C: CLEAN, R: REPLACE, A: ADJUST, L: LUBRICATE
(1) Check and clean and adjust or replace, if necessary, before every journey.
(2) Replace every 2 years or 20000 Km (12427 mi).
(3) Replace every 4 years.
(4) Check at each engine start.
(5) It is recommended to lubricate stands and footrests periodically with spray grease after use in particularly hard conditions
(dirty with salts, dust, etc.) or after long inactivity periods.
km x 1,000
Exhaust pipe flange bolts
Spark plugs
Carburetion at idle (CO)
Throttle body
Stands (5)
Transmission cables and controls
Alternator belt
Steering bearings and steering clearance
Wheel bearings
Brake discs
Air filter
Engine oil filter
Fork
Vehicle general operation
Braking systems
Light circuit
Safety switches
Brake fluid (2)
Clutch fluid (2)
Gearbox oil
Engine oil
Fork oil / oil seals
Final drive oil
Tyres - pressure / wear (1)
Engine idle speed
Valve clearance adjustment
Wheels
Bolts and nuts tightening
Battery terminals tightening
Wheel nipple tightening (1)
Cylinder synchronisation
Footrests joint (5)
Suspension and setting
Engine oil pressure warning light (4)
Empty oil drain pipe from the filter housing
Fuel lines (3)
Brake lines (3)
Clutch wear
Brake pad wear (1)
Labour time (minutes)
R
OUTINE MAINTENANCE TABLE
1.5 10
I
R
I
I
I I
I I
I
I I
I
R R
I
I I
I I
I I
I
I I
I I
R R
R R
R
R R
I I
A A
A A
I I
I I
I
I I
I I
I
I
C
I
I
I
I I
140 220
20 30 40 50
I I
R R R R
I I I I
C C
I I I I
I I I I
A A R
I I I I
I I I I
I I I I
R I R I
R R R R
I I
I I I I
I I I I
I I I I
I I
R I R I
I I I I
R R R R
R R R R
R R
R R R R
I I I I
A A A A
A A A A
I I I I
I I I I
I I
I I I I
I I I I
I I I I
I I
C C C C
I I I I
I I I I
I I I I
I I I I
200 220 200 230
Maintenance
60 70 80
I I
R R R
I I I
C C
I I I
I I I
A A
I I I
I I I
I I I
R I R
R R R
I I
I I I
I I I
I I I
I I
R I R
I I I
R R R
R R R
R
R R R
I I I
A A A
A A A
I I I
I I I
I I
I I I
I I I
I I I
I I
C C C
I I I
I I I
I I I
I I I
200 220 200
MAIN - 31