Removing The Side Panels; Installing The Front Cowling Left Inner Panel 2 - Yamaha FJR1300AS(X) Service Manual

ET3P61037

REMOVING THE SIDE PANELS

1. Remove:
• Side panel "1"
NOTE:
To release a pin on the side panel "1" from its
corresponding hinge on the side cowling "2",
push the end "a" of the hinge with a flathead
screwdriver.
a
ET3P61038
INSTALLING THE FRONT COWLING LEFT
INNER PANEL 2
1. Install:
• Front cowling left inner panel 2
M MMM M MMM M M MMM M
EC3P61038
CAUTION:
When installing the panels onto the vehicle,
be careful not to damage the panels or the
vehicle itself.
a. Turn the main switch to "ON", and then open
the accessory box lid.
b. Turn the handlebar completely to the left.
c. Install the adjusting knob shaft "1" onto the
left headlight beam adjusting cable "2".
d. Place front cowling left inner panel 2 "3" be-
tween the front cowling assembly and the
steering stem.
2
1
M MMM M M MMM M M MMM M
1
2
3
e. Fit the top and side of inner panel 2 into the
front cowling assembly to the left of the meter
assembly.
f. Fit inner panel 2 under the right side of the ac-
cessory box.
MMM
NOTE:
Pull the front cowling assembly outward when
fitting the panel under the accessory box.
g. Fit the lower left corner of inner panel 2 into
the front cowling assembly in front of the ac-
cessory box, making sure to align the bolt
hole in the panel with the bolt hole in the cowl-
ing.
h. Push inner panel 2 inward, under the meter
assembly.
4-9
GENERAL CHASSIS