Removing And Installing Rear Left Vent Warm Air And Cold Air Flap Control Motor V220 - Audi Air conditioning 2003 A8 Workshop Manual

8.10 Removing and installing rear left vent
warm air and cold air flap control motor
-V220-
Note
On vehicles with a rear Climatronic operating and display unit
♦
-E265- (optional extra), this control motor only actuates the left
flap in the rear air duct.
On vehicles with no rear Climatronic operating and display unit
♦
-E265- , this control motor actuates the flaps for the left and
right side in the rear air duct (the shafts of the flaps are inter-
connected).
On vehicles with a rear Climatronic operating and display unit
♦
-E265- , pay attention to the arrangement of the connectors to
the two control motors -A- ( rear left vent warm air and cold air
flap control motor -V220- ) with connecting element -C- („red"
colour) and control motor -B- ( rear right vent warm air and cold
air flap control motor -V221- ) with connecting element -D-
(„blue" colour) and mark if necessary to avoid possible inter‐
change.
In cases of doubt about correct connector assignment, unplug
♦
the connector from one control motor for example and then
interrogate the fault memory of the front operating and display
unit, Climatronic control unit -J255- ⇒ "Guided fault-finding"
function of vehicle diagnostic, testing and information system
VAS 5051.
Removing
– Switch off ignition.
– Remove the centre console. ⇒ Body Repairs; Rep. gr. 70
– Remove the air duct from the centre console ⇒ Body Repairs;
Rep. gr. 68
– Remove the bolts -A-.
– Detach the control motor -B-.
– Use 2 screwdrivers -C- to prise off the connecting element
-D-.
Installing
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
8. Components for control and regulation of air conditioner located in passenger compartment
Audi A8 2003 ➤
Air conditioning - Edition 09.2010
85