Removing And Installing Right Centre Vent Control Motor V111; Removing And Installing Centre Vent Temperature Sender G191 - Audi Air conditioning 2003 A8 Workshop Manual

8.3 Removing and installing right centre
vent control motor -V111-
Note
Mark the motor/flap connecting element on removal to avoid
♦
interchange with the connecting elements of other control mo‐
tors.
In the event of the fault „Upper or lower limit value exceeded",
♦
check the motor/flap connecting element. It must be properly
attached to the motor and there must not be any clearance
between the control motor mount and the connecting element.
In the event of „clicking noise" from the area of the control mo‐
♦
tor, check the connection of the lug of the connecting element
at the control motor to the vent adjustment levers. Such noise
may be produced if the lug does not engage properly between
the two adjustment levers.
– Remove the glove compartment ⇒ General body repairs, in‐
terior; Rep. gr. 68 .
– Switch on ignition.
– Set the air distribution at the front operating and display unit,
Climatronic control unit -J255- to dash panel vents and open
the two dash panel vents -A- and -B-.
– Pull the right centre dash panel vent -B- out of the dash panel
⇒ General body repairs, interior; Rep. gr. 70 .
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
– Remove/re-install the right dash panel vent and control motor
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
in the same manner as described for the left dash panel vent
⇒ page 76 .
8.4 Removing and installing centre vent
temperature sender -G191-
– Switch off ignition.
– Remove the centre console ⇒ General body repairs, interior;
Rep. gr. 70 .
– Remove the storage compartment beneath the dash panel on
the left and the steering column support to the transmission
tunnel ⇒ General body repairs, interior; Rep. gr. 68
8. Components for control and regulation of air conditioner located in passenger compartment
Audi A8 2003 ➤
Air conditioning - Edition 09.2010
79