MV Agusta Brutale 675 Workshop Manual page 466

BRAKES
Brake lever and pedal soft ("spongy")
Brake lever or pedal stiff
Braking action insufficient
Brake pads rub against brake disks
EXHAUST SYSTEM
Exhaust noise excessive
Engine performance poor
COOLING SYSTEM
Engine temperature high
Engine temperature low
O
Diagnostic
Air bubbles in hydraulic circuit
Leaks in hydraulic circuit
Caliper seals damaged
Pump seals damaged
Caliper pistons do not slide freely
Brake fluid level low
Brake discs distorted
Brake lever or pedal bent
Disks dirty
Air bubbles in hydraulic circuit
Leaks in hydraulic circuit
Caliper seals damaged
Pump seals damaged
Caliper pistons do not slide freely
Brake fluid level low
Brake discs distorted
Brake pad springs damaged
Brake discs distorted
Caliper pistons do not slide freely
Brake fluid level too high
Brake pads worn down
Exhaust pipe damaged
Exhaust pipe fasteners loose
Exhaust pipe damaged
Exhaust pipe fasteners loose
Coolant level low
Cooling fan faulty
Expansion tank cap faulty
Instrument temperature sensor faulty
Thermostat locked in closed position
Radiator fins bent or obstructed
Radiator scaly
Water pump damaged
Injection/ignition system faulty
Fuel unsuitable
Engine cooling circuit faulty
Spark plug heat grade unsuitable
Carbon formation in cylinder head/piston
Thermostat locked in open position
- 8 -
Bleed
Repair
Replace
Replace
Check
Top up
Replace
Replace
Clean
Bleed
Repair
Replace
Replace
Check
Top up
Replace
Replace
Replace
Check
Adjust
Replace
Replace
Tighten
Replace
Tighten
Top up
Replace
Replace
Replace
Replace
Repair/Clean
Clean
Replace
Check
Change
Check
Replace
Clean
Replace