Buell 2002 X1 Handbook page 53

HOME
WHEELS
GENERAL
Good handling and maximum tire mileage are directly related
to the care of wheels and tires. Regularly inspect wheels and
tires for damage and wear. If handling problems occur, see
1.25 TROUBLESHOOTING
See 1.9 TIRES AND WHEELS
inflated to the recommended air pressure. Always balance
the wheel after replacing a tire.
11 1
WARNING
Do not inflate any tire beyond its maximum inflation
pressure as specified on tire sidewall. Overinflation may
cause tire to suddenly deflate which could result in death
or serious injury.
TROUBLESHOOTING
See Figure 2-4. Check tire inflation pressure at least once
each week. At the same time, inspect tire tread for punctures,
cuts, breaks and other damage. Repeat the inspection before
long trips.
CHECK FOR
Loose axle nuts.
Excessive side-play or radial (up-and-down)
play in wheel hubs.
Alignment of rear wheel in frame or with
front wheel.
Rims and tires out-of-true sideways; should
not be more than 0.080 in. (2.03 mm).
Rims and tires out-of-round or eccentric
with hub; should not be more than 0.090 in.
(2.29 mm).
Irregular or peaked front tire wear.
Correct tire inflation.
Correct tire and wheel balance.
Steering head bearings.
Damper tubes.
Shock absorbers.
Swingarm bearings.
2-6
or Table 2-3.
for tire pressures. Keep tires
WARNING
Table 2-3. Wheel Service
Tighten front axle nut (metric) with LOCTITE THREADLOCKER 243 (Blue)
to 48-53 ft-lbs (65-72 Nm). Tighten rear axle nut (metric) to 66-73 ft-lbs (90-
99 Nm).
Replace wheel hub bearings.
Check Axle Alignment
swingarm as described under
Replace rims. See
Replace rims. See
Replace as described under
2.8 TIRES.
Inflate tires to correct pressure. See
Static balance may be satisfactory if dynamic balancing facilities are not
available. However, dynamic balancing is strongly recommended.
Correct adjustment and replace pitted or worn bearings. See
ING HEAD
Check for leaks. See
Check damping action and mounts. See
ADJUSTMENTS.
Check for looseness. See
b0195x2x
Figure 2-4. Checking Tire Inflation Pressure
REMEDY
under 1.11 DRIVE BELT DEFLECTION
2.19 SWINGARM.
2.8 TIRES.
2.8 TIRES.
2.5 FRONT
1.9 TIRES AND
BEARINGS.
2.16 FRONT FORK.
2.19 SWINGARM.
or repair
WHEEL, 2.6 REAR WHEEL
WHEELS.
1.17 STEER-
1.15 SUSPENSION DAMPING
2002 Buell X1: Chassis
2.4
and