Xerox DocuPrint N2025 Service Manual page 24

Comments On LIne Message
Close Covers
Insert MBF
Install
Print Cartridge
Duplex Jam
Open Rear Cover
Clear Paper Path
Exit Jam-Open
Rear & Top Cover
Remove Print Car-
tridge
Clear Paper Path
Paper Jam
Open Top Cover
Remove Print Car-
tridge
Clear Paper Path
MBF misfeed Paper Jam
Open Top Cover
Lift /Extend MBF
Remove All Paper
Tray 1 Misfeed Tray 1 Jam
Open Tray 1
Lift/Extend MBF
Open Top Cover
Remove Printery
Clear Paper Path
Status Indicator Repair Analysis Procedures
Error Code Table
Table 1 Error Code Table
Fault History Entry Diagnostic Message
E5: Top/R Cover
E5: MBF Extend
J3: EP Cartridge
E7-1 E7: Duplex Jam
E4-0 E-4: Exit Jam
E3-1 E3: Reg. Jam
E2-1M E2-1 Misfeed Jam
E2-11 E2-1 Misfeed Jam
02/2000
Error Description
1. Top cover interlock is open.
2. Rear cover interlock is open.
MBF Assy. is not closed.
1. Print Cartridge is not installed
2. The installed Print Cartridge is not
the correct one.
1. Duplex Sensor is not actuated
within the time after the start of the
Duplex drive motor in reverse.
2. Duplex sensor is being actuated at
power up.
3. Duplex Sensor is on when the inter-
lock is closed.
1. Exit sensor is not deactuated within
time after it is actuated.
2. Exit sensor is being actuated at
power up.
3. Exit Sensor is ON when the inter-
lock is closed.
4. Exit Sensor turns from OFF to ON
at Erase Cycle.
Exit Sensor did not actuate within time
after the Registration clutch is actuated.
1. Simplex printing: Reg. Sensor is
OFF when the specified time has
passed timing from Feed Roll ON.
2. Printing from 2000 Sheet Feeder:
Reg. Sensor is OFF when the tim-
ing is after receiving Feed_Run sta-
tus.
1. Simplex printing: Reg. Sensor is
OFF when the specified time has
passed timing from Feed Roll ON.
2. Printing from 2000 Sheet Feeder:
Reg. Sensor is OFF when the tim-
ing is after receiving Feed_Run sta-
tus.
2-6
Action
Close Top Cover
Close Rear Cover
Go to RAP 58
Close MBF
Install the Print Cartridge, or
replace with the correct Print
Cartridge
Go to RAP 13
Open the Rear Cover and
remove any paper.
Go to RAP 57
Open Top Cover, remove EP
Cartridge and remove any
paper.
Go to RAP 11
Open Top Cover, remove EP
Cartridge and remove any
paper.
Go to RAP 10
Open Top Cover or Feeder and
remove the sheets. Then close
the cover.
Go to RAP 8
Open Top Cover or Feeder and
remove the sheets. Then close
the cover.
Go to RAP 8
Initial Issue
DocuPrint N2025/N2825