Battery - Yamaha XZ550RJ 1982 Service Manual

3. Specific gravity readings after a long, slow
charge indicate a cell to be lower than any
others.
4. Warpage or buckling of plates or insulators
is evident.
WARNING:
Battery fluid is poisonous and dangerous,
causing severe burns, etc. It contains sulfuric
acid. Avoid contact with the skin, eyes, or cloth-
ing.
Antidote: EXTERNAL - Flush with water.
INTERNAL — Drink large quantities of water or
milk. Follow with milk of magnesia, beaten
eggs, or vegetable oil. Call physician immedi-
ately.
Eyes: Flush with water for 15 minutes, and get
prompt medical attention. Batteries produce
explosive gases. Keep sparks, flame, ciga-
rettes, etc. away. Ventilate when charging or
using in an enclosed space. Always shield your
eyes when working near batteries.
KEEP OUT OF REACH OF CHILDREN.
The service life of a battery is usually two to
three years. Lack of care, as described be-
low, will shorten the life of the battery:
•
Negligence in keeping battery
topped off with distilled water;
•
Battery left discharged;
•
Over-charging with heavy charge;
•
Freezing;
•
Filling with tap water or sulfuric
acid containing impurities;
•
Improper charging voltage or cur-
rent on new battery;
If the motorcycle is not to be used for a long time,
remove the battery and have it stored. The follow-
ing instructions should be observed:
1. Recharge the battery periodically
2. Store the battery in a cool, dry place.
3. Recharge the battery before reinstallation.

Battery

Electrolyte
Initial charging current
Recharging current
Refill fluid
Refill period
YB16AL
Specific gravity: 1.280
1.6 amp for 10 hours (new
battery)
10 hours (or until specific
gravity reaches 1.280)
Distilled water (to maximum
level line)
Check once per month (or
more often, as required)
178