Troubleshooting - Polaris Sportsman 700 Efi 2005 Service Manual

TROUBLESHOOTING

Spark Plug Fouling
Spark plug cap loose or faulty
S
Incorrect spark plug heat range or
S
gap
PVT system calibrated incorrectly/
S
components worn or mis-adjusted
Fuel quality poor (old) or octane too
S
high
Low compression
S
Restricted exhaust
S
Weak ignition (loose coil ground,
S
faulty coil, stator, or ETC switch)
ETC switch mis-adjusted
S
Restricted air filter (main or
S
pre-cleaner) or breather system
Improperly assembled air intake
S
system
Restricted engine breather system
S
Oil contaminated with fuel
S
Engine Turns Over But Fails to Start
No fuel
S
Dirt in fuel line or filter
S
Fuel will not pass through fuel valve
S
Fuel pump inoperative/restricted
S
Tank vent plugged or pinched
S
Engine flooded
S
Low compression (high cylinder
S
leakage)
No spark (Spark plug fouled)
S
ignition component failure
Engine Does Not Turn Over
Dead battery
S
Starter motor does not turn
S
Engine seized, rusted, or
S
mechanical failure
Engine Runs But Will Not Idle
Restricted carburetor pilot system
S
Low compression
S
Crankcase breather restricted
S
Engine Idles But Will Not Rev Up
Spark plug fouled/weak spark
S
Broken throttle cable
S
Obstruction in air intake
S
Air box removed (reinstall all intake
S
components)
Incorrect or restricted carburetor
S
jetting
ETC switch limiting speed
S
Reverse speed limiter limiting
S
speed
Incorrect ignition timing
S
Restricted exhaust system
S
Cam worn excessively
S
Engine Has Low Power
Spark plug fouled
S
Cylinder, piston, ring, or valve wear
S
or damage (check compression)
PVT not operating properly
S
Restricted exhaust muffler
S
Cam worn excessively
S
ENGINE
3.59