Easy Checker(Tm) - Kubota M100GX Operator's Manual

40 OPERATING THE TRACTOR
BEasy Checker(TM)
If the warning lamps in the Easy Checker(TM) come on
during operation, immediately stop the engine, and find
the cause as shown below.
Never operate the tractor while Easy Checker(TM) lamp is
on.

(1) Easy Checker(TM)

Engine warning
This indicator serves the following two functions. If the
indicator lights up, pinpoint the cause and take a
proper measure.
1. Error with the engine control system
If during operation the water temperature gauge reads
an acceptable level but the warning lamp in the Easy
Checker(TM) comes on, stop the engine and get it
restarted. If the error happens again, consult your local
KUBOTA Dealer.
A If the warning indicator lights up, the following
phenomena may appear depending on the engine's
trouble spot.
A The engine stops unexpectedly.
A The engine fails to start or gets interrupted just
after start.
A The engine output is not enough.
A The engine output is enough, but the warning
indicator stays on.
If the engine output is not enough, immediately
interrupt the operation and move the tractor to a safe
place and stop the engine.
2. Engine overheat
If the water temperature gauge reads an unusual level
and the warning lamp in the Easy Checker(TM) comes
on, the engine may have got overheated. Check the
tractor by referring to "TROUBLESHOOTING" section.
Engine oil pressure
If the oil pressure in the engine goes below the
prescribed level, the warning lamp in the Easy
Checker(TM) will come on.
If this should happen during operation, and it does not
go off when the engine is accelerated to more than
1000 rpm, check level of engine oil.
(See "Checking Engine Oil Level" in "DAILY CHECK"
in "PERIODIC SERVICE" section.)
Fuel level
If the fuel in the tank goes below the prescribed level,
the warning lamp in the Easy Checker(TM) will come
on. (less than 38 L.)
If this should happen during operation, refuel as soon
as possible.
(See "Checking and Refueling" in "DAILY CHECK" in
"PERIODIC SERVICE" section.)
A When the fuel warning lamp lights up, refuel the tank
as soon as possible. If the tractor runs out of fuel and
stalls, the engine and its components may be
damaged.
Air cleaner
If the air cleaner is clogged, the warning lamp in the
Easy Checker(TM) will come on.
If this should happen during operation, clean the air
cleaner element.
(See "Cleaning Air Cleaner Primary Element" in
"EVERY 100 HOURS" in "PERIODIC SERVICE"
section.)
Electrical charge
If the alternator is not charging the battery, the Easy
Checker(TM) will come on.
If this should happen during operation, check the
electrical charging system or consult your local
KUBOTA Dealer.
Master system warning
If trouble should occur at the engine, transmission,
hydraulic or other control parts, the indicator flashes
as a warning. If the trouble is not corrected by
restarting the tractor, consult your local KUBOTA
Dealer.
A For checking and servicing of your tractor, consult
your local KUBOTA Dealer for instructions.