Pm Warning Level And Required Procedures - Kubota M100GX Operator's Manual

20 OPERATING THE ENGINE
BPM Warning Level and Required Procedures
In the Inhibit Mode, the buzzer starts sounding and the indicator display changes in response to the PM level in order to
prompt the operator to perform the required procedure listed below.
A Once the regeneration level has been reached, immediately perform the required procedure for regeneration.
Interrupting the regeneration cycle or continued operation by ignoring the warning signs may cause DPF and engine
damage.
DPF system status
PM warning level: 1
Buzzer: Not sounding
PM warning level: 2-1
Buzzer: Sounding
every 5 seconds
PM warning level: 2-2
Buzzer: Sounding
every 3 seconds
PM warning level: 3 If the parked regeneration cycle is interrupted or the tractor is continuously operated in the PM
warning level 2:
Buzzer: Constantly
sounds
Engine output: 50%
PM warning level: 4 If the regeneration cycle is interrupted or the tractor is continuously operated ignoring the warning
signs, in the PM warning level 3:
Buzzer: Constantly
sounds
Engine output: 50%
Inhibit Mode
The indicator starts flashing.
Regeneration with the Auto Mode is possible. If the regeneration conditions are met,
select the Auto Mode. Refer to "Operating Procedure for Auto Regeneration Mode".
Parked regeneration indicator starts
flashing.
The engine warning indicator starts
flashing.
The parked regeneration indicator starts
flashing
The engine warning indicator remains
constantly "ON".
Required procedure
A specific level of PM has built up in the
DPF muffler.
Move the tractor to a safe area, then follow
the "Operating Procedure for Parked
Regeneration".
Immediately stop working the tractor, move
the tractor to a safe area, then follow the
"Operating Procedure for Parked
Regeneration".
If the tractor is operated further and the
operator ignores the warning signs, then
regeneration will be disabled.
Immediately move the tractor to a safe
place and place in park, turn "OFF" engine.
Contact your local KUBOTA Dealer.
A At this level never continue to operate
the tractor, otherwise damage may
result to the DPF and engine.