Weil-McLain CGi Series 3 Installation And Maintenance Manual page 44

CG i
GAS-FIRED wATER BOILER- sERIEs a -
Boiler Manual
9c
Operating instructions
CGi-4
• Spark pilot • Natural or propane gas
44
• Gas valve: HoneyweiiVR8204NR8304
- FOR YOUR SAFETY READ BEFORE OPERATING -
IAWARNINGI Ifyou do
~~!follow
these.lnstructions exactly, a fire or explosion may result causing property damage,
personal InJUry or loss of lrfe.
A.
This appliance does not have a pilol.lt is equipped
with an ignition device which automatically lights
the burner. Do not
try
to light the burner by hand,
C. Use only your hand to turn the gas control knob. Never use tools.lfthe
knob wil not tum by hand, don1 try to repair it, call a qualified service
technician. Force or attempted repair may result in a fire or explosion.
B.
BEFORE OPERATING, smel all around the
appliance area for gas. Be sure to smell next to the
floor because some gas Is heavier than air and wil
settle
on the floor. See below.
D. Do not use this appliance if any part has been under water.
Immediately cal a qualified service technician to inspect the appliance
and to replace any part of the control system and any gas controt
which has been under water.
WHAT TO DO IF YOU SMELL GAS
Do not try to lght any appliance,
Do not touch any electric switch; do not use any
phone in your building,
Immediately call your gas supplier from a neighbor's phone. Follow
the gas supplier's instructions.
If
you cannot reach your gas supplier, call the fire departmenl.
OPERATING INSTRUCTIONS
1. STOP! Read the safety information above on this label.
2. Set the thermostat to lowest setting.
3. Tum off all electrical power to the appliance.
4. Remove jacket front paneL
5. This appliance is equipped with an ignition device which automatically lghts the
burner. Do
.!121
try to light the burner by hand,
6. Tum Gas control knob clockwise r>. to "OFF."
7. Wait five (5) minutes to clear out any gas. Then smel for gas, Including near the
floor. If you smel
gas, STOP! Follow "B" In the safety Information above.lf you
don1 smell gas, go to the next step.
8. Tum Gas control knob counterclockwise ..:"'\ to "ON."
9. Tum on al electric power to the appliance.
10. Set thermostat to desired setting.
11.11 the appliance will not operate, follow the instructions "TO TURN OFF GAS TO
APPLIANCE" below and cal your service technician or gas supplier.
12. Replace jacket front panel.
Hoooywol
VR8204
or
VR8304
Gas vatve
Honeywoll
VR82040
Gas valve
TO TURN OFF GAS TO THE APPLIANCE
1. Set thermostatto lowest setting.
2. Turn offal electric power to the appliance if service is to be
performed,
3..
Remove jacket front panel.
4. Tum Gas control knob clockwise r>. to "OFF." Do notforce.
5, Replace jacketfront panel.
550·223-237(1108)
Part
Number
550-142-780/0712