Weil-McLain CGi Series 3 Installation And Maintenance Manual page 42

CG
i
GAS- FIRED wATER
eo1LER-
sERIEs
a-
Boiler Manual
9c
Operating instructions .
Spark pilot • Natural or propane gas
CGi-25, 3, 5, & 6 •
Gas valve: White-Rodgers 36E
- FOR YOUR SAFETY READ BEFORE OPERATING -
! A
WARNING! If you do not fo!low these instructions
exactl~,
a fire or
explo~lon
may result caus10g property damage,
personal~njury
or loss of hfe.
A. This appliance Is equipped with an Ignition device
which automatically lights the pilot. Do not try lo
light the pilot by hand.
B. BEFORE OPERATING, smell all around the
appliance area for gas. Be sure to smell next to the
floor because some gas is heavier than air and will
settle on the floor. See below.
C.
Use only your hand to tum the gas control knob. Never use tools. lfthe
knob will not tum by hand, don~ try to repair it, call a qualified service
technician. Force or atlempted repair may result in
a
fire or explosion.
D. Do not use this appliance
n
any part has been under water.
Immediately call a qualified service technician to Inspect the appliance
and to replace any part of the control system and any gas control,
which has been underwater.
WHAT TO DO IF YOU SMELL GAS
• Do nottry to light any appliance.
Do not touch any electric switch; do not use any
phone in your building.
• Immediately call your gas supplier from a neighbor's phone. Follow
the gas suppliefs instructions.
• If you cannot reach your gas supplier, call the fire department.
OPERATING INSTRUCTIONS
1. STOP I Read the safety information above on this label.
2. Setthe thermostatto lowest setting.
3. Tum off all electrical power to the appliance.
4. Remove front panel.
5. This appliance is equipped with an ignition device which
automatically lights the pilot. Do
.!!2l
try to light the pilot by
hand.
6. Tum gas control knob clockwise
n..
to "OFF."
Position
indicator
Gas
control
knob
7. Wait five (5) minutes to clear out any gas. Then smell for gas,
including near the floor. If you smell gas, STOP! Follow "B" in
the safety information above. If you don't smell gas, go to the
next step.
8.
Tum gas control knob counterclockwise ......, to "ON."
9. Tum on all electric power to the appliance.
10.
Set thermostat to desired setling.
11. If the appliance will not operate, follow the instructions "To
Tum Off Gas To The Appliance" and call your service
technician or gas supplier.
12. Replacefrontpanel.
TO TURN OFF GAS TO THE APPLIANCE
1.
Setthe thermostltto lowest setling.
3.
Remove front panel.
2. Turn off all electric power to the appliance if service is to be 4. Tum gas control knob clockwise
n..
to "OFF." Do notlorce.
performed. 5. Replace front panel. 550-223-042 0906
42 Part
Number 550-142-780/0712