Weil-McLain CGi Series 3 Installation And Maintenance Manual page 43

CG
i
GAS- FIRED wATER
eotLER-
sERIEs
3 -
Boiler Man ual
9c
Operating instructions .
Spark pilot • Natural or propane gas
CGi-25, 3, 5, thru 8 •
Gas valve: White-Rodgers 36C
- FOR YOUR SAFETY READ BEFORE OPERATING -
IA WARNINGI
If you do not follow these Instructions exactly, a fire or explosion
may result causing property damage, personal injury or loss of life.
A. This appliance is equipped with an ignition device
which aulomatical ly lighls the pilot. Do
M.t
try to
llghtthe pilot by hand.
B. BEFORE OPERATING, smell all around the
appliance area for gas. Be sure to smell next to the
floor because some gas is heavier than air and will
settle on the floor. See below.
C. Use only your hand to depress or turn the gas control knob. Never use
tools.lf the knob will not depress or turn by hand, don't try to repair
i~
call a qualified service technician. Force or attempted repair may
result Ina fire or explosion.
D. Do not use this appliance if any part has been under water.
Immediately call a qualified service technician to Inspect the appliance
and to replace any part of the control system and any gas control,
which has been under water.
WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance.
• Do not touch any electric switch; do not use any
phone in yourbuilding.
• Immediately call your gas supplier from a neighbor's phone. Follow
the gas supplier's Instructions.
If you cannot reach your gas supplier, call the fire department.
OPERATING INSTRUCTIONS
1. ST OP! Read the safety Information above on this label.
2.
Setthe thermostatto lowest setting.
3. Tum off all electrical power to the appliance.
4. Removefrontpanel.
5. T his appliance is equipped with an ignition device which
automatically lights the pilot. Do not try to light the pilot by
hand.
6. D epress gas control knob slightly and tum clockwise r.. to
"OFF." Note: Knob cannot be turned to "OFF" unless knob
is depressed slightly. Do not force.
Position
ind icat or
lsl!own in
· ·ON' posalon)
-
Gas
control
knob
7. Wait five (5) minutes to clear out any gas. Then smell for gas,
including near the floor. If you smell gas, STOP I Follow "B" in
the safety information above.lf you don't smell gas, go to the
next step.
8. Tum gas control knob counterclockwise
n
to "ON."
9. Tum on all electric power to the appliance.
10. Set thermostat to desired setting.
11. If the a . p pliance will not operate, follow the instructions "To
Tum Off Gas To The Appliance" and call your service
technician orgas supplier.
12. Replace front panel.
TO TURN OFF GAS TO THE APPLIANCE
1. Setthethermostattolowestsettlng. 3.
2. Turn off all electric power to the appliance if service is to be 4.
performed.
Remove front panel.
Depress gas control knob slightly and turn clockwise
r..
to
"OFF." Donotforce.
5. Re lacefront anel.
550·223-043{ 0906)
Part Number 550-142-780/0712
43