Weil-McLain CGi Series 3 Installation And Maintenance Manual page 41

CG
i
GAS- FIRED wATER
eotLER-
sERIEs
3 -
Boiler Man ual
9c
Operating instructions
CGi-25, 3, 5, & 6
• Spark pilot • Natural or propane gas
• Gas valve: HoneyweiiVR8204NR8304
FOR YOUR SAFETY READ BEFORE OPERATING
!A
WARNING! If you do not fo.llow these instructions
exactl~, ~
fire or
explo~ion
may result causmg property damage, personalmJury or loss ofhfe.
A. This appliance is equipped with an ignition device
which automatically lights the pilot. Do not try to
light tile pilot by hand.
B. BEFORE OPERATING, smell all around the
appliance area for gas. Be sure to smell next to the
floor because some gas is heavier than air and will
settle on the floor. See below.
C. Use only your hand to turn the gas control knob. Never use tools. If the
knob will not turn by hand, don't try to repair it, call a qualified service
technician. Force or attempted repair may result in a fine or explosion.
D. Do not use tills appliance If any part has been under water.
Immediately call a qualified service technician to inspect the appliance
and to replace any part of the control system and any gas control,
which has been underwater.
WHAT TO DO IF YOU SMELL GAS
• Do nottry to light any appliance.
• Do not touch any electric switch; do not use any
phone In your building.
• Immediately call your gas supplier from a neighbo(s phone. Follow
the gas supplier's instructions.
• If you cannot neach your gas supplier, call the fire department.
OPERATING INSTRUCTIONS
1. STOP I Read the safety information above on this label.
2. Set thethermostatto lowestsettlng.
3. Turn off all electrical power to the appliance.
4. Remove front panel.
5.
This appliance is equipped with an ignition device which
automatically lights the pilot. Do
!!2l
try to light the pilot by
hand.
6. Turn gas control knob clockwise
A
to "OFF."
u ...---.Gas
~
...::='
0
control
knob
7. Wait five {5) minutes to clear out any gas. Then smell for gas,
including near the floor. If you smell gas, STOP I Follow "B" in
the safety information above. If you don't smell gas, go to the
next step.
8. Turn gas control knob counterclockwise
r>
to "ON."
9. Turn on all electric power to tile appliance.
10. Setthermostattodesiredsetting.
11. If the appliance will not operate, follow the instructions ''To
Turn Off Gas To The Appliance" and call your service
technician orgas supplier.
12. Replace front panel.
TO TURN OFF GAS TO THE APPLIANCE
1. Setthe thermostatto lowest setting. 3. Remove front panel.
2. Tum off all electric power to the appliance if service is to be 4. Turn gas control knob clockwise
A
to "OFF." Do notforce.
performed. 5.
Replace front panel.
550-223.()41 (0906)
Part Number 550-142-780/0712
4 1