Will Burt EXPEDITION RANGER MAST Operator's Manual page 7

™ M '
R O M
ANGER AST PERATOR S ANUAL
Figure 4-35 Lower to Ground ................................................................................................................... 4-16
Figure 4-36 Stake the Base Plate ............................................................................................................ 4-17
Figure 4-37 Tighten Guy Lines................................................................................................................. 4-17
Figure 4-38 Lock the Upper Clamp and Unlock the Lower Clamp .......................................................... 4-18
Figure 4-39 Insert Top Tube from the Top of the Tripod ......................................................................... 4-18
Figure 4-40 Lower Top Tube until There is One Hand Width from the Bottom of the Tube and Lock the
Lower Clamp ............................................................................................................................................ 4-19
Figure 4-41 Slide Carriage Assembly onto the Top Tube ........................................................................ 4-19
Figure 4-42 Tip Tube ................................................................................................................................ 4-20
Figure 4-43 Insert Tip Tube...................................................................................................................... 4-20
Figure 4-44 Ensure the Eyelet is on the Backside of the Mast ................................................................ 4-20
Figure 4-45 Ensure the Platform Stub Goes Between the Edges of the Carriage .................................. 4-20
Figure 4-46 Side Bracket ......................................................................................................................... 4-21
Figure 4-47 Back View ............................................................................................................................. 4-21
Figure 4-48 Insert Long Pins .................................................................................................................... 4-21
Figure 4-49 Pick an Angle for the Extension Arm and Pin into Place ...................................................... 4-21
Figure 4-50 Arm Not Extended ................................................................................................................ 4-21
Figure 4-51 If Required, Extend and Pin .................................................................................................. 4-21
Figure 4-52 Cup Holder ............................................................................................................................ 4-22
Figure 4-53 Connect the Bolster Plate to the Carriage ............................................................................ 4-22
Figure 4-54 Connect Cable to the Carriage ............................................................................................. 4-23
Figure 4-55 Feed Through Pulley ............................................................................................................ 4-23
Figure 4-56 Connect to Eyelet ................................................................................................................. 4-23
Figure 4-57 Guy Lines .............................................................................................................................. 4-24
Figure 4-58 Hook to Guy Plate ................................................................................................................ 4-24
Figure 4-59 Single Line to Collar ............................................................................................................. 4-24
Figure 4-60 Raise Tripod Legs................................................................................................................. 4-24
Figure 4-61 Adjust Legs as Needed and Consult Bubble Level to Ensure Tripod is Level ..................... 4-25
Figure 4-62 Stake the Tripod ................................................................................................................... 4-25
Figure 4-63 Attach Base Plate to Winch Tube ......................................................................................... 4-26
Figure 4-64 Drive the Stakes a Distance Equal to the Mast Height from the Center of the Mast ........... 4-26
Figure 4-65 Drive Each Stake into the Ground at a 45° Angle ................................................................ 4-27
Figure 4-66 Unlock Winch Spool ............................................................................................................. 4-27
Figure 4-67 Use the Hitch Pin to Attach the Handle to the Winch ........................................................... 4-27
Figure 4-68 Prepare Guy Lines ................................................................................................................ 4-28
Figure 4-69 Cable Path Shown in Red .................................................................................................... 4-28
Figure 4-70 Add Slack to Cable ............................................................................................................... 4-28
Figure 4-71 Line Up ................................................................................................................................. 4-29
Figure 4-72 Push Tube Up ....................................................................................................................... 4-29
Figure 4-73 Button in Notch ..................................................................................................................... 4-29
Figure 4-74 Push Tube Up ....................................................................................................................... 4-29
Figure 4-75 Lock Lower Clamp ................................................................................................................ 4-29
Figure 4-76 Lock J-hook .......................................................................................................................... 4-30
Figure 4-77 J-hook Locked ...................................................................................................................... 4-30
Figure 4-78 Stake the Base Plate ............................................................................................................ 4-30
TP-4549901-G v
February 2024