Carburetor - Suzuki UG110 2021 Service Manual

• Properly install the air cleaner element into the air cleaner case.
5
* When installing the air cleaner element, have the large
mesh side of the element face out.
* Be sure to position the air cleaner element snugly and
correctly, so that no incoming air will by-pass it. Re-
member, rapid wear of the piston rings and cylinder
bore is often caused by a defective or poorly fitted air
cleaner element.

CARBURETOR

THROTTLE CABLE PLAY
Inspect initially at 1 000 km (1 month) and every 6 000 km
(6 months) thereafter.
Throttle cable play A should be 2 – 4 mm as measured at the
throttle grip when turning the throttle grip lightly. If the throttle
cable play A is incorrect, adjust it as follows:
• Loosen the locknut 1 and turn the adjuster 2 in or out until
the specified play is obtained.
• Tighten the locknut 1 while holding the adjuster 2.
4 Throttle cable play A: 2 – 4 mm
!
After the adjustment is completed, check that handlebar
movement does not raise the engine idle speed and that
the throttle grip returns smoothly and automatically.
ENGINE IDLE SPEED
• Adjust the throttle cable play. (See above.)
• Warm up the engine.
NOTE:
Make this adjustment when the engine is hot.
• Remove the maintenance lid 1.
• Connect the multi circuit tester to the high-tension cord.
2 09900-25008: Multi circuit tester set
PERIODIC MAINTENANCE 2-7