Starter System And Side-Stand/Ignition Interlock System; Trouble Shooting - Suzuki DL1000 Service Manual

7-10 ELECTRICAL SYSTEM
STARTER SYSTEM AND SIDE-STAND/IGNITION INTERLOCK
SYSTEM
Starter
motor
Starter relay

TROUBLE SHOOTING

Starter motor will not run.
The transmission is in neutral. Grasp the
clutch lever, turn on the ignition switch
with the engine stop switch in the "RUN"
position and listen for a click from the
starter relay when the starter button is
pushed.
No click
Measure the starter relay voltage at the
starter relay connectors (between
) when the starter button is
pushed.
Voltage
Continued on next page
To ECM and
Ignition coil
Y/G
B/Y Starter
Clutch lever
button
position switch
B/W
No voltage
Engine stop
switch
O/W
O/B
Turn signal/
G
side-stand relay
Check if the starter motor runs
when its terminal is connected
Clicks
to the battery
not use thin "wire" because a
large amount of current flows)
Runs
• Faulty starter relay
• Loose or disconnected starter
• Faulty ignition switch
• Faulty engine stop switch
• Faulty clutch lever position
• Faulty gear position switch
• Faulty turn signal/side-stand
• Faulty starter button
• Poor contact of connector
• Open circuit in wire harness
Ignition
switch
Fuse (30 A)
R
Fuse Gear position
(15A) switch
Bl
side-stand
switch
terminal (Do
Does not run
• Faulty starter motor
motor lead wire
switch
relay