Malaguti XTM 50 2007 Manual page 170

Checking the steering
Periodically check the condition of the steering system. Worn or
loose steering bearings may cause danger. Place a stand under
the engine to raise the front wheel off the ground. Hold the lower
ends of the fork legs and try to move them forward and backward.
If any free play can be felt, have a
repair the steering. This check is easier if the front wheel is re-
moved.
Securely support the vehicle so that there is no danger
of it falling over.
Wheel bearings
If there is play in the bearings of the front and rear wheel or the
wheel does not spin smoothly, have a
the wheel bearings.
Dealer check or
MALAGUTI
Dealer check
MALAGUTI
ENGLISH
PERIODIC MAINTENANCE AND MINOR REPAIR
BATTERY
E
V
Removing the battery
Remove the seat, release the battery from the elastic band, E,
and disconnect the terminals by removing the screws, V.
Checking
Check the electrolyte level and make sure the terminals are firmly
tightened. If necessary, add distilled water to raise the level to the
maximum mark.
Also check cables and retaining bolts for oxidation or corrosion.
Clean thoroughly or replace if damaged. Upon completion of this
operation, apply a thin coat of grease or vaseline to the
terminals.
When checking the battery, make sure breather hose T
is properly installed. If the hose is touching the chassis
or if its position makes the fluid seep onto the chassis,
the vehicle may get damaged.
T
6
47