Firebox Panels Installation - Town & Country Fireplaces TC36 Instruction Manual

TC36 & TC36 ARCH
PANELS
ADJUSTABLE "V" BRACKET
REAR LOWER PANEL
Figure 57: TC36D Panel V-brackets.
The lower rear panel is held tight
against the side panels by two "V"
brackets located on the rebox rear
wall (Figure 57). Although the brackets
are adjusted at the factory for the best
t, some adjustment may be neces-
sary. Adjust the angle of the bracket
by hand to ensure a snug t.
Note - the TC36 Arch has a one
piece rear panel and therefore has
no "V" brackets.
HEAT SHIELD
FIREBOX
LIP
Figure 58: TC36D Side panel retainer.
5056.427D

Firebox Panels Installation

PARK AVE. HERRINGBONE 2 ................................... TCPN.36PAC(TC36)
...................................................................................
MOUNT VERNON RED BRICK 2 ............................... TCPN.36VRC(TC36)
...................................................................................
MANHATTAN STACKED BRICK 2 ............................. TCPN.36MNC(TC36)
...................................................................................
BLACK PORCELAIN ................................................. TCPN.757031.C(TC36)
...................................................................................
COFFEE BEAN BROWN PORCELAIN ..................... TCPN.757031CB.C(TC36)
...................................................................................
TITANIUM .................................................................. TCPN.757031.TI (TC36)
...................................................................................
...................................................................................
COPPER .................................................................... TCPN.757031.CU (TC36)
...................................................................................
(See Porcelain panel instruction manual for speci c instructions for these panels).
Before proceeding see burner instructions.
A Firebox Panel Set must be installed for safe operation. Do not use the re-
place without panels. Unpack and inspect all panels. The panels need to be
installed before the logs are in place.
Caution: The Firebox Panels are very fragile, and should be handled with care.
1. Remove the Side Panel Retainer located on the underside of the rebox
heat shield. The retainer slips between the lip of the rebox and the heat
shield and is retained in place by two screws (Figure 58 and Figure 59).
2. Install the Lower Rear Panel (the TC36 Arch has a one piece rear panel).
SIDE PANEL
RETAINER
Figure 59: TC36D Side panel retainer screw location.
TC36 & TC36 ARCH PANEL SETS
SCREWS
34
TCPN.36ARPAC(TC36 ARCH)
TCPN.36ARVRC(TC36 ARCH)
TCPN.36ARMNC(TC36 ARCH)
TCPN.75702.C(TC36 ARCH)
TCPN.75702CB.C(TC36 ARCH)
TCPN.75702.TI (TC36 ARCH)
TCPN.75702.CU (TC36 ARCH)
TC36_D & TC36_DAR_101215-52