APRILIA RSV mille 956X Service And Repair Manual page 18

RSV mille
=
FOLLOW
Product
®
LOCTITE 574 orange (**)
®
LOCTITE Anti Seize 15378 (**)
MOLYKOTE ® G-n (**)
SILASTIC 732 RTV (**)
0
Bimol Grease 481
LUBERING ST grease
AP-LUBE
temporary lubricant
DID CHAIN LUBE grease
"Biosolvent"
frame detergent
"ACRILON 28"
cyanoacrylic glue
MOTUL MOTOWASH
degreaser
Code
0899784 – Fastening of coolant thermal switch.
– Fastening of coolant thermistors.
– On neutral gear switch contact screw.
– On the outer surface of the engine oil pump motor.
– On the cylinder's base where it rests on the engine casing.
0297434 – On gearshift primary and secondary shaft.
– On gearshift primary and secondary shaft housings.
– On driving shaft and countershaft.
– On the gearshift primary shaft housing and toothing.
0297433 – On main bush housings.
– On main bushes.
– On engine casing bearing housings.
– On coolant pump shaft.
– On valve guide slots on the head.
– On valve guide edges.
– On driving shaft and countershaft bush housings.
– On driving shaft and countershaft housings.
– On connecting rod/piston pin slots.
– On camshaft cams.
– On starter motor fastening housing.
0297386 – On cable bracket on flywheel cover.
– On camshaft sensor cable.
8116053 – Assembly of front and rear wheel seals.
– Assembly of fork pin bearings.
– Assembly of clutch pump control rod.
– On rear wheel pin thread.
– On steering head bearings.
– Assembly of rear brake pump control rod.
– On rear brake lever pin.
– On intermediate timing gear thrust washer.
– Upper countershaft oil seal.
– Starter motor gear.
8116038 – Assembly of cold-start control.
- – Assembly of handlebar counterweights rubber element.
– Assembly of throttle cable adjuster rubber elements.
– Assembly of rubber element on gearshift lever.
– Insertion of radiator lower pins on supporting rubber elements.
– Assembly of breather pipe on radiator and three-way manifold.
– Assembly of coolant couplings on radiators.
– Assembly of water and fuel drainage pipes on fuel pump flange.
– Assembly of throttle body torsion springs.
– Lubrication of driving chain.
8116031 – Washing of engine oil tank.
8116945 – Assembly of air filter casing seal.
- – Cleaning of frame and fork.
GENERAL INFORMATION
Description of use
=
FOLLOW
1 - 13